Isuzu 2009 MY N Series - NLR55, NMR55 models Maintenance Schedule

0A-44 General Information
NLR55, NMR55 models (1/2)
LNW90AXF000801
I : Inspect, clean, or repair or replace as required A : Adjust R : Replace T : Tighten to the specified torque L : Lubricate Service interval 1 5 10 15 20 25 30 35 40 45 50 55 60 65 70 75 80 85 90 95 100 105 Odometer reading or months,
x1,000 miles 0.6 3 6 9 12 15 18 21 24 27 31 34 37 40 43 46 49 52 55 59 62 65 whichever comes first
Engine oil
- R R R R R R R R R R R R R R R R R R R R R or every 3 months
Engine oil filter
- - R - R - R - R - R - R - R - R - R - R - or every 6 months
Fuel filter
- - - - R - - - R - - - R - - - R - - - R - or every 12 months
Air cleaner element
- - I - I - I - R - I - I - I - R - I - I - or every 24 months
Idle speed and acceleration
- - - - I - - - I - - - I - - - I - - - I - or every 12 months
Valve clearance
I - - - - - - - A - - - - - - - A - - - - - or every 24 months
Looseness in or damage to fuel tank cap and fuel line
- - - - - - - - I - - - - - - - I - - - I - or every 24 months
Drive belt tension and damage
I - I - I - I - I - I - I - I - I - I - I - or every 6 months
Engine coolant
- - - - - - - - R - - - - - - - R - - - - - or every 24 months
Damage to or looseness in exhaust pipe, exhaust brake, exhaust throttle, and their mounting
- - - - I - - - I - - - I - - - I - - - I - or every 12 months
Cooling system Intake system
- - - - I - - - I - - - I - - - I - - - I - or every 12 months - - - - - - I - - - - - I - - - - - I - - - or every 12 months
Engine operating conditions
- - I - I - I - I - I - I - I - I - I - I - or every 6 months
Clutch fluid
- - I - I - I - R - I - I - I - R - I - I - or every 24 months
Clutch pedal stroke and free play
- I I I I I I I I I I I I I I I I I I I I I or every 3 months
Transmission oil
- - - I - - I - - R - - I - - I - - R - - I or every 24 months
Gear control mechanism looseness
- - - - - - - - I - - - - - - - I - - - - - or every 24 months
Gear control cable
- - - - A - - - A - - - A - - - A - - - A - or every 12 months
Propeller shaft, universal joints and sliding sleeves
- - - - L - - - L - - - L - - - L - - - L - or every 12 months
Loose propeller shaft joints
- - I - I - I - I - I - I - I - I - I - I - or every 6 months
Propeller shaft spline wear
- - - - - - - - I - - - - - - - I - - - - - or every 24 months
Looseness in propeller shaft bearings and related components
- - - - - - - - I - - - - - - - I - - - - - or every 24 months
Propeller shaft center bearing
- - - - L - - - L - - - L - - - L - - - L - or every 12 months
Differential gear oil
- - I - I - I - R - I - I - I - R - I - I - or every 24 months
King pin (model with rigid front suspension)
- - L - L - L - L - L - L - L - L - L - L - or every 6 months
Oil leaks from power steering system
- - I - I - I - I - I - I - I - I - I - I - or every 6 months
Power steering fluid
- - - - - - - - R - - - - - - - R - - - - - or every 24 months
Looseness in or damage to power steering system
* * * * * * * * *
mounting
- - I - I - I - I - I - I - I - I - I - I - or every 6 months
Looseness in connection between knuckle and front axle
- - I - I - I - I - I - I - I - I - I - I - or every 6 months
Looseness in or damage to steering mechanism
- - - - - - - - I - - - - - - - I - - - - - or every 24 months
Steering wheel free play
- I I I I I I I I I I I I I I I I I I I I I or every 3 months
Steering mechanism functionality
- I I I I I I I I I I I I I I I I I I I I I or every 3 months
Wheel alignment
- - - - - - - - I - - - - - - - I - - - - - or every 24 months
Power steering hose
- - - - - - - - - - - - - - - - R - - - - - or every 48 months
x1,000 km
*
: The vehicle needs to be maintained more often if it is driven in severe condition. Refer to "Maintenance Schedule for Severe-condition" in this section.
LGGEN-WE-0871_7th.book 44 ページ ２００９年１０月１日 木曜日 午後３時２６分
mechanikar