Page 36
NOTE: To supply the correct part it is important that
you state the model number, serial number and type
of gas when applicable. This information is on the
rating plate inside the heater.
11.2 Parts List
The following three pages contain a parts list,
general exploded view and detailed exploded views to
aid in parts identification. Please refer to these pages
when ordering parts for your Lite2 pool/spa heater.
MAIN GAS ASSEMBLY
1 Burner Tray Assy, NAT - 125-400 R0316901-05
1 Burner Tray Assy, LPG - 125-400 R0319501-05
2 Burner Tray, Shelf Only 125-400 R0317001-05
3 Gas Valve, NAT - All R0317100
3 Gas Valve, LPG - All R0319600
4 Gas Orifice, NAT 0 - 3,000 ft alt. (EA.) (Note 1) All L0032200
4 Gas Orifice, LPG 0 - 5,000 ft alt. (EA.) (Note 2) All L0032900
5 Anti-Rotation Bracket All 10835900
6 Burner, Main All L0052300
7 Burner Manifold 125 L0052200
7 Burner Manifold 175 L0006300
7 Burner Manifold 250 L0006400
7 Burner Manifold 325 L0006500
7 Burner Manifold 400 L0006600
ELECTRICAL SYSTEM
8 Temperature Control Assembly - LD All R0011700
9 Wire Harness Assembly All 10457800
10 Plate Assembly All 10594600
11 Knob, Single Bar All R0099900
12 Temperature Control Label All H0166500
13 Temperature Sensor All R0011800
14 Protector Sleeve, Bulb All 10444900
15 "O" Ring, Temperature Control Bulb All E0116400
16 Thermostat Knob, Black All R0010700
17 Stop Plate, "Temp-Lok" All 10583100
18 Temperature Control Gasket All S0070000
19 Bezel All S0069800
20 Stop Plate Screw (Not Shown) All F0033300
21 Temperature Sensor Retainer Bracket All 10447300
22 Retainer Bracket Screw All F0009100
23 Pressure Switch & Siphon Loop Assembly (2 PSI)All R0097600
24 Pressure Switch, 2 PSI All R0013200
24 Pressure Switch, 1 PSI All R0011300
24 Pressure Switch, 1-10 PSI All R0015500
25 Siphon Loop Assembly All R0057800
26 High-Limit Switch Assembly All R0023200
27 High-Limit Switch, 135° F All R0022700
28 High-Limit Switch, 150° F All R0023000
29 High-Limit Switch Retainer Boot All S0098900
30 High-Limit Switch Wire Harness All 10419300
31 High-Limit Switch Retainer Clip All 10418400
32 High-Limit Switch Cover All 10418300
33 Fusible Link Assembly All R0012200
34 Fusible Link Bracket All 10479900
35 Terminal Block All R0097800
36 Ignition Control Assembly All R0344600
37 Ignition Control All R0408100
38 Harness Assembly (Not Shown) All R0059800
39 Transformer (115V/220V-24V) (Not Shown) All
R0061100
40 Ignition Control Panel (Not Shown) All 10451200
41 In-Line Fuse Assembly (Not Shown) All 10480000
42 Ignitor All R0317200
VENT SYSTEM
43 Top Enclosure 125-400 R0343401-05
44 Top Filler Plate 125-400 R0343701-05
45 Rainshield Kit 125-400 R0318301-05
46 Flue Collector Assembly 125-400 R0316401-05
47 Outdoor Vent Cap 125-400 10561501-05
48 Indoor Drafthood 125-400 10561401-05
49 Flue Transition Plate 125-400 10861901-05
50 Adapter Plate 125-400 10535301-05
50 Clip All 10211000
52 Flue Collector Hold Down Clamp All 10726000
WATER SYSTEM
53 Inlet/Outlet Header, 2" All R0056400
53 Inlet/Outlet Header, Bronze, 2" All R0016800
54 Return Header (Includes set of 9 gaskets) All R0058300
54 Return Header, Bronze (Includes set of 9 gaskets)All R0054600
55 Header Bolt Assembly (Set of 8) All R0057000
56 Bolt for Headers, 2 1/2" All F0046100
57 Washer for Headers All F0011100
58 Nut for Headers All F0003100
59 Header Gasket Assembly (Set of 18) All R0050800
60 Flange & Gasket Assembly (Set of 2 ) All R0055000
61 Flange, 2" All 10573500
62 Flange Gasket, 2" All S0078000
63 Flange Sleeve, 2" All S0078200
64 Flange Bolt All F0031700
65 Flange Gasket, 1 1/2 - 2" All S0078100
66 Rubber Grommet for Drain Plug All R0316300
67 Grommet, Slitted (Not Shown) All S0071100
68 Brass Connector Body All P0019701
69 Brass Drain Plug 1/4" All P0026800
70 Brass Plug, 3/4" All P0027000
71 By-Pass Assembly w/o spring (Iron Cap) All R0013100
71 By-Pass Assembly with spring (Bronze Cap) 125-400 10701401-05
72 By-Pass Valve Rod All S0079800
73 Brass Nut (For Rod) All F0048400
74 By-Pass Valve Disc All R0011500
75 By-Pass Valve Control Cap (Iron) All 10452200
75 By-Pass Valve Control Cap (Bronze) All 10557400
76 Control Cap Bolts (2 Required) All F0041600
77 By-Pass Valve Spring, Purple 125 S0079900
77 By-Pass Valve Spring, White 175 S0061400
77 By-Pass Valve Spring, Red 250 S0061300
77 By-Pass Valve Spring, Blue 325 S0061200
77 By-Pass Valve Spring, Black 400 S0070100
78 By-Pass Valve Gasket All R0011400
79 Heat Exch. Tube Assy. (Incl. set of 18 gaskets) 125-400 R0018101-05
80 Heat Exchanger Baffle (8 Required) 125-400 10697401-05
81 Baffle Retainer All S0083900
82 Heat Exchanger Support Clip (2 Required) All 10457000
83 Flow Restrictors (2 Required) (Not Shown) 125 S0000300
84 Heat Exchanger End Baffles (2 Required) 125-400 R0332301-05
FIREBOX COMPONENTS
85 Complete Combustion Chamber Assy. 125-400 R0316701-05
JACKET COMPONENTS
86 Door with Latch 125-400 R0343601-05
87 Jacket Assembly, Less Top Assembly 125-400 R0343501-05
88 Gap Closure, Inlet/Outlet All R0344300
89 Gap Closure, Return All R0344400
90 Button Plug, 1-3/4" All F0035300
91 Button Plug, 7/8" All F0032300
92 Button Plug, 2" (With hole for gas line) All F0056600
OPTIONAL COMPONENTS
Non Combustible Base 125-400 10521701-05
Pressure Relief Valve 3/4" NPT, 75 PSI All R0040400
Touch Up Spray Paint, Grey All R0335800
Flame Sense Rod, Retrofit All R0334300
Igniter Condensate Shield, Retrofit Kit All R0334200
Notes:
1. For altitudes 2,000 Ft above sea level, call factory for orifice size.
2. For altitudes 5,000 Ft above sea level, call factory for orifice size.
Key Model Order
No Description No Part No.
Key Model Order
No Description No Part No.
To Next Page
Loading...
