Kubota V3300-T-E2B - Page 65

S-2
V3300-E2B, V3300-T-E2B, WSM
DIESEL ENGINE
W1014322
Symptom Probable Cause Solution
Reference
Page
Engine Revolution Is
Not Smooth
Fuel filter clogged or dirty Replace G-11, 12
Air cleaner clogged Clean or replace G-10, 23
Fuel leak due to loose injection pipe retaining nut Tighten retaining nut S-30
Injection pump malfunctioning Repair or replace S-21, 42
Incorrect nozzle opening pressure Adjust S-22, 23,
30
Injection nozzle stuck or clogged Repair or replace S-22, 23,
30
Governor malfunctioning Repair S-37, 38
Turbocharger bearing worn out Replace the
turbocharger
assembly
S-27, 29
Turbocharger shaft bent Replace the
turbocharger
assembly
S-27, 29
Turbocharger fin or other part damaged due to
foreign matters
Replace the
turbocharger
assembly
S-27, 29
Either White or Blue
Exhaust Gas Is
Observed
Excessive engine oil Reduce to specified
level
G-6, 8
Piston ring and cylinder worn or stuck Repair or replace S-49, 50,
67, 72
Incorrect injection timing Adjust S-20
Oil Leak into Exhaust
Pipe or Suction Pipe
Waste oil pipe clogged or deformed Repair or replace S-29
Turbocharger’s piston ring seal faulty Replace the
turbocharger
assembly
S-29
Either Black or Dark
Gray Exhaust Gas Is
Observed
Overload Reduce the load –
Low grade fuel used Use specified fuel 4
Fuel filter clogged Replace G-11, 12
Air cleaner clogged Clean or replace G-10, 23
Deficient nozzle injection Repair or replace
nozzle
S-22, 23,
30
KiSC issued 06, 2006 A