What to do if a Kubota WSM L3560 has black exhaust gas?
If you notice black or dark gray exhaust gas from your Kubota Tractor, it could stem from a few issues. The filter comp (DPF) might be clogged, requiring replacement. You may be using low-grade fuel; switch to the specified fuel. A clogged fuel filter could also be the culprit, so change it. Additionally, check for a clogged air cleaner (clean or change it) or a damaged injector (replace it).
What causes Kubota Tractor engine to overheat?
If your Kubota Tractor is overheating, several potential causes exist. Insufficient engine oil or coolant levels could be the issue; ensure they are filled to the prescribed level. A broken or elongated fan belt may be the problem, requiring a change or adjustment. The radiator net and fins might be clogged with dust, necessitating cleaning. Corrosion inside the radiator or coolant flow route could also lead to overheating, so clean or replace the affected parts. A damaged radiator or radiator cap would also need replacement. Finally, using unsuitable fuel can cause overheating, so use the specified fuel.
Why is the Kubota WSM L3560 output deficient?
If your Kubota Tractor has deficient output, it could be due to several reasons. The engine's moving parts might be stuck, requiring repair or replacement. The supply pump or injector could be damaged, also needing replacement. A compression leak could be present, necessitating an examination of compression pressure and subsequent repair. The air cleaner might be clogged (clean or replace the element). There could be air leakage from the compressor discharge side, in which case you should replace the turbocharger assembly. Lastly, the breather hose or CCV might be clogged with ice, requiring you to melt the ice or replace the affected parts.
Why is Kubota Tractor engine revolution not smooth?
If your Kubota Tractor's engine revolution isn't smooth, several factors could be at play. The fuel filter may be clogged or dirty, requiring a change. The air cleaner might be clogged, needing cleaning or replacement. A fuel leak could be present due to a loose injection pipe retaining nut, so tighten it. The fuel supply pump might be malfunctioning, necessitating replacement. The injector could be stuck or clogged, also requiring replacement. Issues with the turbocharger, such as a worn bearing, bent shaft, or damaged fins/components, would require replacing the turbocharger assembly.
What to do if Kubota WSM L3560 starter does not run?
If the starter on your Kubota Tractor isn't running, it could be due to a discharged battery (charge it), a malfunctioning starter (repair or replace it), a malfunctioning main switch (repair or replace it), improperly adjusted or damaged safety switches (adjust or replace them), a damaged starter relay (replace it), or disconnected wiring (connect it).
Why does Kubota WSM L3560 have low oil pressure?
If your Kubota Tractor has low oil pressure, it could be due to insufficient engine oil (fill it), a clogged oil strainer (clean it), excessive oil clearance of the bearings (replace the metal, bushing, or shaft), using the wrong type of oil (use the specified type), or a damaged oil pump (replace it).
What causes excessive oil consumption in Kubota WSM L3560?
Excessive lubricant oil consumption in your Kubota Tractor could be due to several reasons: the piston ring's gap points in the same direction (shift ring gap direction), a worn or stuck oil ring (replace it), a worn-out piston ring groove (replace the piston and piston ring), or worn-out valve stem and guide (replace them).
Why is my Kubota WSM L3560 Tractor emitting blue exhaust gas?
If you see white or blue exhaust gas from your Kubota Tractor, it could be due to excessive engine oil (reduce to the specified level) or worn/stuck piston rings and cylinder (repair or replace).
Why is fuel mixing into oil in Kubota WSM L3560 Tractor?
If fuel is mixing into the lubricant oil of your Kubota Tractor, it could be due to a damaged injector (replace it) or oil dilution due to regeneration (change the engine oil).
What causes high oil pressure in Kubota WSM L3560?
High oil pressure in your Kubota Tractor can be caused by using a different type of oil than specified (use the specified type) or a breather hose or CCV clogged due to ice (melt the ice or replace).
General| Type | Compact Utility Tractor |
|---|---|
| Engine Model | Kubota V1505-T |
| Horsepower | 37 hp (27.6 kW) |
| Fuel Type | Diesel |
| Drive | 4WD |
| Hydraulic System | Open center |
| 3-Point Hitch | Category I |
| PTO Horsepower | 30.5 hp (22.7 kW) |
| Transmission | Hydrostatic |
| Number of Gears | 3-range |
| Height | 91.3 in (232 cm) |
| Tire Size (Front) | 7-16 |
| Tire Size (Rear) | 15-19.5 |
| Displacement | 91.4 cu. in. (1, 499 cc) |
To Next Page