- 49 -
OIL
nd.
er the engine has
heck bolt.
AE#90
y:
ns i
1. Pla put a container
n
2. Rem
the
3. Rei
4. Fill th
for l
im
TRANSMISSION GEAR
Check the transmission gear oil tank for leakage.
s main stand on level grou
1. Place the scooter on it
Proceed with the following steps aft
been shut off for 2 – 3 minutes.
2. Remove the oil filter bolt (1) and check the oil level (2).
e hole. If the level is
It should be up to the brim of th
low, add oil to raise it to the proper level.
3. After refilling, securely tighten the c
Recommended Gear Oil: S
hange Capacit
Capacity/Exc
0.12/0.09L (50cc)
0.21/0.18L (125/200cc)
Tra m ssion Oil Replacement
• Add gear oil through the oil check bolt hole (2).
• After refilling, use a rag to wipe clean.
• Not enough or too much gear oil will affect
engine performance.
• Never use a different brand or inferior
quality gear oil. Engine breakdown may
occur.
• Change the gear oil at the first 300km and
then change again at every 4000km. Add
specified gear oil whenever necessary.
ce the scooter on level ground and
u der the engine.
o olt (1) and drain plug (3) to drain
ve the oil filter b
oil.
ns
tall the drain plug and tighten.
e engine with oil and install the oil filter bolt.
up for a few minutes and check
5. Start the engine, warm it
oi leakage. If oil leakage is found, stop the engine
me
diately and look for the cause.
To Next Page
General
