Page 18
Each compressor is energized by a corresponding com-
pressor contactor.
ξ±ξ²ξ·ξ¨ξξ΅ξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξΏξξξξξξξ
operation. If Interlink compressor replacement is neces-
ξξξξξξξξξξξξξξξξξξξξξξξξξξ
IMPORTANT
Some scroll compressors have an internal vacuum
protector that will unload scrolls when suction
pressure goes below 20 psig. A hissing sound
will be heard when the compressor is running
unloaded. Protector will reset when low pressure
in system rises above 40 psig. DO NOT REPLACE
COMPRESSOR.
2-Crankcase Heaters HR1, HR2
ξ€ξξξξ―ξͺξ·ξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξ«ξξξξξξξ«ξ΅ξξξξξξξ-
ξξξξξξξξξξξξξξξξξξξξξξξξξξξ₯ξξξξξξξξξξξξξξ«ξ΅ξξξξξξξξξξξξξξξ
around compressor B2. Crankcase heater wattage varies
by compressor size.
3-High Pressure Switches S4, S7
The high pressure switch is an auto-reset SPST N.C.
switch which opens on a pressure rise. All units are
ξξξξξξξξξ ξξξξξ ξξξξξ ξξξξξξξξ ξ²ξξ ξΏξξξξξ
ξξ ξξξξξξξξ ξξξξξξξ ξξξξ
switch is located in the compressor discharge line. On al-
ξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξ
line in the blower section. Switches are wired in series
with the compressor contactor coil.
ξ²ξξξξξξξξξξξξξξξξξξξξξσ°©ξξξξξξξξξξξξξξξΆξξξξΏξξξξξξξξξξξξξξξξξ
ξΆξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξ
ξξξξξξξξξξξξξξξξξξξξξξξξξξξξξ²ξξξξξξξξξξξξξξσ°©ξξξξξξξξξξξξξξ
only S4 is used. S4 is located on the common compressor
discharge line and is wired to both compressor contactors
ξξξξξξξξξ€ξξξξΈξξξξξ¦ξξξξξξξξξξ
ξΊξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξ
ξξξξξξ³ξξξξξξξξξξξξξξξξξξξξξ
ξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξ
opens and the respective compressor is de-energized (the
economizer can continue to operate). When discharge
ξξξξξξξξξ ξξξξξξ ξξξ ξξξξ ξξ ξξξ ξξξξξ ξξξξξξ ξξ ξξξξ ξξ³ξξξ ξξξξ
pressure switch will close.
ξ·ξξξξ€ξξξξΈξξξξξ¦ξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξ
ξξξξξξ
locking out. This means the control allows three high pres-
sure trips per one thermostat demand. The control can be
reset by breaking and remaking the thermostat demand or
manually resetting the control.
4-Filter Drier
ξ―ξͺξ·ξ ξξξξξξ ξξξξξ ξξ ξΏξξξξξ ξξξξξξ ξξξξξξξξ ξξξ ξξξξ ξξξξξξξ ξξξξξ ξξξ
each refrigerant circuit. The drier removes contaminants
and moisture from the system.
5-Low Pressure Switches S87, S88
The low pressure switch is an auto-reset SPST N.O.
switch (held N.C. by refrigerant pressure) which opens on
a pressure drop. All units are equipped with this switch.
ξ·ξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξΆξξξ
(compressor one) and S88 (compressor two) are wired to
ξ€ξξξξΈξξξξξ¦ξξξξξξξξξξξξ€ξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξ-
es by shunting the switches during start up until pressure
ξξξξξξξ
ξξξξξξξξξ€ξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξ
ξξξξξξξξξξξξξξξξξξξξξξξξΏξξξξξξξξξξξξξξξξξξξξξξξξ
ξξξξξξξξξξ
compressor is locked out. The control is reset by breaking
and remaking the thermostat demand or manually reset-
ting the control.
ξΊξξξξ ξξξξξξξξ ξξξξξξξξξ ξξξξξξ ξξξ ξξξ +ξ ξξ ξξξξξ ξξξξξ ξξ ξξξ
ξξ³ξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξ
compressor( s) is(are) de-energized. The switch automat-
ξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξ+
ξξξξξξξξξξξξξξξξξξξ³ξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξ-
erant being added.
6-Condenser Fans B4 and B5
ξΆξξξξΆξ³ξ¨ξ¦ξ¬ξ©ξ¬ξ¦ξ€ξ·ξ¬ξ²ξ±ξΆξξξξ
ξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξ
ξξξξξξξξξξΏξξξξξξξξ ξξξ ξξξξξξξξξξξξξξξξξξξξ ξξξ ξξξξξξξξξξξξ€ξξξ
condenser fans have single-phase motors. The fan as-
sembly may be removed for servicing and cleaning.
7-Temperature Sensors RT46, RT47, RT48 & RT49
Units are equipped with four factory-installed thermistors
ξξ΅ξ·ξξξξξξ΅ξ·ξξξξξξξξξξξξξξξξξσ°¨ξξξξξξξξξξξξξξξξξξξξξξξξξξξξ-
ant circuit.
The thermistors provide the Unit Controller with constant
ξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξξΏξξξξξξξξξξξξξξξξξξξξξ-
frigeration circuit. These temperatures are used as feed-
back in certain modes of unit operation.
ξ¨ξξξξξξξξξξξξξξξξξξξξξ
ξξξξξξξξΏξξξξξξξξξξξξξξξξξξξξξξξξξξξξξ
ξξξξξξξξξξ ξξξξ ξξξ ξξξξξξξξξ ξξξξξξ ξξξξξξξξ ξΆξξξ ξΏξξξξξ ξξ ξξξξξ
ξΏξξξξξξξξξξξξξξξξξξξξξξξξ