Leone ARROW - Chapter Eighth Troubleshooting

USER MANUAL LEONE ARROW E-SCOOTER • 17
Chapter eight: TROUBLESHOOTING
Problem Condition Check Solution
When I turn
my Vehicle on no-
thing happens.
1. No Indications on the
display.
1.Check the main
breaker under the seat
if it is on “ON” position.
2. Check power
Connection
and battery level.
1. Flip the breaker lever on
“ON”
2. Fasten connections.
2.Power indication light
is on
3. Check battery and
motor connection
3. Clean and fasten battery
terminal connectors.
4. Fasten the motor
connections. With the controller
under seat.
3.Power indication light
is on and the brake light
is “on”.
4. Check the brake
levers if they return to
normal position.
5. Loosen the brake. If there
is any corrosion replace. Contact
the supplier.
6. Charge or replace
battery. Contact the supplier.
5 . Battery voltage is
below 42 volts.
The Throttle does not
work or switch on,
the vehicle moves
without acceleration.
1. The Throttle does not
return to stop position.
1. Check the grip for
damage
2. Check the Throttle
spring.
3. The Throttle handle if
it is loose
1. Use a at head screwdriver
to adjust the gap between the
rubber handle and the cover.
2. Re-adjust the throttle spring
position. Contact
the supplier
3. Check Throttle connections.
Contact the
supplier.
The range is low
Charger light is
o
1. Bad connection bet-
ween the charger and
the battery.
2. Charger doesn’t
charge
1. Check the charger plug
position.
2. Replace the charger
Battery doesn’t hold the
charge
1. Connections between
the batteries are
not good
2. Bad battery cell
1. Check all connections between
the batteries
2. Replace the bad
battery cell
The brakes are not
working
properly
1. Brake levers go too
deep
2. No braking
power
4. Check the brake
1. Adjust the brake cable - see
instructions
2. Clean brake pads using
sand paper or replace