Lovol Phaser Series User Manual

Schedules
A. First service at 20/40 hours or at 1000/2000 km
B. very day or every 8 hours
C. Every 500 hours or six months
D. Every 1500 km or 250 hours
E. Every 5000 km or 1000 hours
The schedules which follow must be applied at the interval (km, hours or months) which occurs first.
A
B
C
D
E
Check the amount of coolant
Check the concentration of coolant (2)
●
●
●
●
●
Check the drive belt(s)
Clean the sediment chamber and the strainer of the fuel lift pump
●
●
Check for water in the fuel pre-filter (1)
●
Renew the fuel filter element(s)
●
Ensure that the atomisers are checked (3)
●
Ensure that the idle speed is checked and adjusted, if it is necessary (3)
●
Check the amount of lubricating oil in the sump
●
●
Check the lubricating oil pressure at the gauge (1)
●
●
Renew the engine lubricating oil (4) (5)
●
●
Renew the canister(s) of the lubricating oil filter (4)
●
Renew the filter of the closed breather system
Clean the air cleaner or empty the dust bowl of the air filter
●
●
●
- extremely dusty conditions
- normal conditions
●
Clean or renew the air filter element, if this has not been indicated earlier
●
Ensure that the turbocharger impeller and turbocharger compressor casing are cleaned
(2)
●
Clean the compressor air filter (1)
●
Ensure that the exhauster or compressor (1) is checked (3)
●
●
Ensure that valve tip clearances are checked and adjusted, if it is necessary (3)
●
Ensure that the alternator, starter motor, etc, are checked (3)
﹙1﹚ If there is one fitted.
﹙2﹚ Antifreeze shall be renewed every 2 years. It must be renewed every 6 month, if using coolant inhibitor to
replace antifreeze.
﹙3﹚ By a person who has had the correct training.
﹙4﹚ The lubricating oil and the filter canister(s) must be renewed every 250 hours or 12 months for applications
where the engine normally runs at full load for periods of more than 20 minutes.
﹙5﹚ The oil change interval will change with the sulphur content of the fuel (see the table below and the Fuel
Specification in section 5). The interval to change the canister of the lubricating oil filter is not affected.
Fuel sulphur content (%>) Oil change interval
﹤0.5
Normal
0.5-1.0 0.75 of normal
﹥1.0
0.50 of normal
4.03

Lovol Phaser Series Specifications

General

Brand	Lovol
Model	Phaser Series
Category	Engine
Language	English