MAGUIRE LPD-100 User Manual

MAGUIRE PRODUCTS INC.
LPD
®
Dryer
LPD
®
Low Pressure Dryer
®
INSTALLATION • OPERATION • MAINTENANCE
Copyright © Maguire Products, Inc. 2010
Models:
• LPD-30
• LPD-100
• LPD-200

MAGUIRE LPD-100 Specifications

General

Brand	MAGUIRE
Model	LPD-100
Category	Dryer
Language	English

Summary

PART 4 Maintenance and Service Procedures

4.1 Clean / Replace Air Filter

Procedure for cleaning or replacing the air filter to maintain dryer performance.

4.2 Cleaning the Vacuum Takeoff Assembly (VTA)

Steps for cleaning the Vacuum Takeoff Assembly (VTA) component of the dryer.

4.3 Canister Removal / Cleaning

How to safely remove and clean the dryer canisters for maintenance.

4.4 Fill Hopper and Fill Valve Cleaning

Instructions for cleaning the fill hopper and fill valve components.

4.7 Adjustments

4.8 Check Out Procedure

A procedure to verify correct assembly and operation after service or maintenance.

4.9 Temperature and Pressure Verification

How to verify temperature and pressure sensor readings for accuracy.

4.11 Diagnostic / Test Mode

PART 5 Troubleshooting and Software Issues

5.1 Alarms – Cause and Solution

Troubleshooting guide for dryer alarms, including causes and solutions.

5.2 Possible Service Issues

Common service issues and their potential causes and resolutions.

5.4 Material Not Drying Correctly

5.5 Dryer Software – Backup, Restore, Factory Reset

PART 6 General Information and Specifications

6.10 Technical Support and Contact Information