Manitowoc SD0303W

To Next Page

To Previous Page

Section 3 Ice Machine Operation

Part Number 80-1620-3 3-1

Section 3

Ice Machine Operation

Component Identification

sv3150

sv3149

Check Valve

Ice Thickness Probe

Dump Valve

Toggle Switch

Water Curtain

Water Distribution Tube

Water Level Probe

Water Pump

Water Inlet Location

Water Inlet Valve

(Located in Refrigeration Compartment)

Bin Switch

Main Page

Default Chapter2
- Safety Notices2
- Table of Contents5
Section 19
General Information9
Model Numbers9
How to Read a Model Number9
Ice Cube Sizes9
Accessories10
- Bin Caster10
- Ice Bagger10
- Guardian Sachet Packets10
- Arctic Pure Water Filter System10
- Manitowoc Cleaner and Sanitizer10
- Aucs® Automatic Cleaning System10
- Dispenser10
Model/Serial Number Location11
Owner Warranty Registration Card12
- General12
Warranty Coverage12
- Parts12
- Labor12
- Exclusions12
- Authorized Warranty Service12
Section 213
Installation Instructions13
General13
Ice Machine Dimensions13
- S320/S420 Air and Water-Cooled Ice Machines13
- S600 Air and Water-Cooled Ice Machines14
- S600 Remote Ice Machines14
- S300/S450/S500/S850/S1000/S1200 Air and Water-Cooled Ice Machines15
- S500/S850/S1000 Remote Ice Machines16
Ice Storage bin Dimensions16
- 30 Inch (76 CM) Ice Storage Bins16
- 22 Inch (56 CM) Ice Storage Bins16
- Inch (130 CM) Ice Storage Bins18
Remote Condenser Dimensions18
- Jc0495/Jc0895/Jc139518
Location of Ice Machine19
Ice Machine Heat of Rejection19
Removing Drain Plug and Leveling the Ice Storage bin20
Air-Cooled Baffle20
Electrical Service21
- General21
- Voltage21
- Minimum Circuit Ampacity21
- Electrical Requirements21
- Maximum Breaker Size & Minimum Circuit Amperage Chart22
Self-Contained Electrical Wiring Connections23
- Self Contained Ice Machine 115/1/60 or 208-230/1/6023
- Self Contained Ice Machine 208-230/3/6023
- Self Contained Ice Machine 230/1/5023
- 115/1/60 or 208-230/1/6023
Remote Electrical Wiring Connections24
- Remote Ice Machine with Single Circuit Model Condenser 230/1/5024
- Or 380-415/3/5024
Water Supply and Drain Requirements25
- Water Supply25
- Water Inlet Lines25
- Drain Connections25
Cooling Tower Applications (Water-Cooled Models)25
- Water Supply and Drain Line Sizing/Connections26
Remote Condenser/Line Set Installation27
- Remote Ice Machines Refrigerant Charge27
- Guidelines for Routing Line Sets28
- Calculating Remote Condenser Installation Distances29
- Lengthening or Reducing Line Set Lengths30
- Connecting a Line Set30
- Remote Receiver Service Valve30
Remote Ice Machine Usage with Non-Manitowoc Multi-Circuit Condensers31
- Warranty31
- Head Pressure Control Valve31
- Fan Motor31
- Internal Condenser Volume31
- Condenser DT31
- Refrigerant Charge31
- Quick Connect Fittings31
- Non-Manitowoc Multi-Circuit Condenser Sizing Chart32
Installation Check List33
Additional Checks for Remote Models33
Before Starting the Ice Machine34
- Aucs Automatic Cleaning System34
Section 335
Ice Machine Operation35
Component Identification35
Sequence of Operation36
- Initial Start-Up or Start-Up after Automatic Shut-Off36
- Freeze Sequence36
- Harvest Sequence37
- Automatic Shut-Off37
- Safety Timers37
- Warm Water Rinse Cycle37
Operational Checks38
- General38
- Water Level38
- Ice Thickness Check38
- Harvest Sequence Water Purge39
General41
Ice Machine Inspection41
Exterior Cleaning41
Cleaning the Condenser41
Water-Cooled Condenser and Water Regulating Valve42
Alphasan42
Guardian43
- Guardian Sachet Replacement Frequency43
- Sachet Installation/Replacement Procedure43
- Clean up Procedure for Damaged Sachet Packet43
Interior Cleaning and Sanitizing44
- General44
- Cleaning Procedure44
- Sanitizing Procedure45
- Removal of Parts for Cleaning/Sanitizing46
Removing the Front Panels52
Removal from Service/Winterization53
- General53
- Self-Contained Air-Cooled Ice Machines53
- Water-Cooled Ice Machines53
- Remote Ice Machines53
- Aucs Accessory53
Checklist55
Safety Limit Feature56

Table of Contents

Related product manuals