MARUTI SUZUKI Swift 2024 - Manual Shut-Off Valve; Manual Shut-Off Valve Operation

6
FOR VEHICLES FITTED WITH CNG FUEL SYSTEM
74L90-74E
MANUAL SHUT-OFF VALVE
75TM00011
Manual shut-off valve (1) is located on the
right hand side of the CNG cylinder.
MANUAL SHUT-OFF VALVE
OPERATION
75TM00012
CNG supply can be switched off by closing
the manual shut-off valve.
Valve closing: Turn the knob towards
direction (A) as shown in figure to close the
CNG supply to Engine.
Valve opening: Turn the knob towards
direction (B) as shown in figure to open the
CNG supply to Engine.
NOTE:
• If the manual shut-off valve is not
opened fully, then the engine may not
run properly.
• If the manual shut-off valve is in closed
condition, it is not possible to fill CNG
into the cylinder.
NOTE:
• As per Government regulation, CNG cyl-
inder needs to be checked and certified
every three (3) years from the date of ini-
tial testing as mentioned on the CNG
cylinder identification plate.
• Customer has to present the vehicle to a
government approved testing agency.
• Failure to test the cylinder may result in
denying of CNG filling by the CNG dis-
pensing stations or may result in confis-
cating the vehicle by enforcement
authorities.
• All the expenses for CNG cylinder test-
ing has to be borne by the customer.
• As per Government regulation, CNG cyl-
inder has to be discarded at 20 years
from the date of initial testing as men-
tioned in the CNG cylinder identification
plate.
• Customer has to discard the cylinder at
his / her expense through government
approved scrap agencies.
• No person shall refill any cylinder, which
has been repaired under sub-rule (2)
with any gas unless a full report on the
repairs and test carried out on the cylin-
der, accompanied by the repairer's certif-
icate of testing are furnished to the Chief
Controller and his permission is obtained
for its refilling.
(1)
(1)
B
A
WARNING
• Never remove the cylinder valve
from the cylinder assembly. For
any assistance consult Maruti
Suzuki authorized workshop.
• Never try to clean the cylinder. In
case of any problem, contact
Maruti Suzuki authorized work-
shop.
• Do not reuse the cylinder valve,
once it is replaced / removed from
cylinder assembly.
• Even if the CNG from the cylinder
is consumed till engine stops,
some amount of CNG will be left
out in the tank under pressure.