HAZARDS AND RISKS
NEVER allow any person to operate the machine without adequate instruction.
ENSURE all operators read, understand and follow the operating instructions.
SERIOUS INJURY could result from improper or careless use of this machine.
Plate compactors are heavy units and should be positioned by two people of appropriate strength. Using the lifting
handles provided on the machine, along with correct lifting techniques.
! MECHANICAL HAZARDS
DO NOT operate the machine unless all protective guards are in place.
KEEP handles and feet clear of rotating and moving parts as they will cause injury if contacted.
ENSURE that the motor operation switch is in the OFF position and the spark plug ignition lead is disconnected before
removing the guards or making adjustments.
ENSURE both the machine and the operator are stable by setting up on level terrain and the machine will not tip over,
slide of fall while in operation or unattended.
DO NOT leave the machine in operation while it is unattended.
ENSURE that the walls of a trench are stable and will not collapse due to the action of the vibration, prior to commencing
compaction.
ENSURE that the area to be compacted does not contain any “live” electrical cables, gas, water or communication
services which may be damaged by the action of vibration.
EXERCISE CARE when operating unit. Exposure to vibration or repetitive work actions may be harmful to hands and
arms.
NEVER stand on the unit while it is operating.
DO NOT increase the governed no-load motor speed above 3,500 r/min. Any increase may result in personal injury and
damage to the machine.
BE CAREFUL not to come in contact with the muffler when the engine is hot, since it can cause severe burns.
ENSURE that the repairs to the motor and machine are carried out by COMPETENT personnel.
! FIRE & EXPLOSION HAZARDS
PETROL is extremely flammable and explosive under certain conditions.
ENSURE that the petrol is only stored in an approved storage container.
DO NOT refuel the motor while it is in operation or hot.
DO NOT refuel the motor in the vicinity of sparks, a naked flame or a person smoking.
To Next Page
Loading...
