MASTERCRAFT TRAILERS
26-1
MasterCraft Trailers
Trailering and Launching
Here are some quick tips for maintaining your trailer in tip-top condition:
• Chips in the paint, especially on the axles and frame result when these surfaces are subjected to repeated or
severe hits by external objects. Usually, this is gravel or asphalt chips thrown up by the rear tires of the tow
vehicles. Over time, rust may develop where paint has been chipped away and this is not covered by the
trailer’s warranty. To avoid this, consider attaching mud flaps behind the tow vehicle’s rear tires.
• To ensure proper operation of the trailer jack, wipe it down and lubricate it on a regular basis.
• If the trailer is backed into salt water, you must completely and thoroughly wash the trailer to ensure that it will
not eventually rust. Salt water is very corrosive, even on galvanized trailers and can corrode the brake system
as well. Exposure to salt water can also cause brake pads to stick and malfunction.
• Check the braking system annually, along with the wheel bearings. If you find anything that appears to be worn,
take the trailer to your MasterCraft dealer for a check and possible repair.
• Always approach the trailer slowly as you prepare to load your boat. This will allow you to retain greater
control. Hard impact with the trailer or improper alignment on the trailer can result in damage to the boat, the
trailer or both, and this is not covered under warranty. Also, if your trailer is equipped with the Boat Buddy
System, a hard hit against it could cause damage, which is also not covered by warranty.
• Disc brakes on the trailer require an additional wire hook-up for the trailer lights. This wire is blue and hooks
to the back-up light wire circuit on the tow vehicle. It’s very important to attach this properly so that the brakes
will disengage when you are backing up.
Introduction
With the purchase of your new, custom-built MasterCraft trailer you have added value to your MasterCraft
boating enjoyment. You can now enjoy almost any of the thousands of recreational waterways in the country.
As the manufacturer, MasterCraft has provided you with a vehicle designed specifically for many years of
To Next Page
Loading...
Need help?
General
