Mercury OUTBOARD MOTOR - Emission Certification Label Details; Owner Responsibility and Maintenance Schedule; Owner Responsibility for Emissions; Inspection and Maintenance Schedule

90-826148R2 MARCH 19971D-0 - IMPORTANT INFORMATION
Table of Contents
Page
Notice to Installer and Owner 1D-1. . . . . . . . . . . .
Boat Horsepower Capacity 1D-1. . . . . . . . . . . . . .
Outboard Remote Control 1D-1. . . . . . . . . . . . . . .
Selecting Accessories For The Outboard 1D-1. .
Selecting Steering Cables and Remote
Control Cables 1D-2. . . . . . . . . . . . . . . . . . . . . . . . .
Locate Centerline Of The Outboard 1D-2. . . . . . .
Lifting Outboard 1D-2. . . . . . . . . . . . . . . . . . . . . . . .
Installing Outboard to Boat Transom 1D-3. . . . . .
Models Without Transom Bracket
Thumb Screws 1D-3. . . . . . . . . . . . . . . . . . . . . .
Models With Transom Bracket
Thumb Screws 1D-4. . . . . . . . . . . . . . . . . . . . . .
Fastening outboard to the boat transom 1D-5
Single Steering Cable and Steering Link
Rod Installation 1D-5. . . . . . . . . . . . . . . . . . . . . . . .
Installing Ride Guide Steering Cable
To The Outboard 1D-5. . . . . . . . . . . . . . . . . . . .
Steering Link Rod Installation 1D-6. . . . . . . . .
Remote Control Installation 1D-6. . . . . . . . . . . . . .
Required Side Mount Remote Control or
Ignition Key Switch Assembly 1D-7. . . . . . . . . . . .
Boats Equipped with Side Mount Remote
Control 1D-7. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Boats Equipped with Panel Or
Console Mount Remote Control 1D-7. . . . . . .
Remote Wiring Connections 1D-7. . . . . . . . . . . . .
Electric Start Remote Control Model 1D-7. . .
Manual Start Models Using Quicksilver
2000 Series Side Mount Remote Control 1D-7
Shift and Throttle Cable Installation
To The Outboard 1D-8. . . . . . . . . . . . . . . . . . . . . . .
Shift Cable Installation 1D-8. . . . . . . . . . . . . . . .
Throttle Cable Installation 1D-9. . . . . . . . . . . . .
Battery Connections 1D-10. . . . . . . . . . . . . . . . . . . .
Set Up Instructions For Oil Injection System 1D-10
Filling The Oil Injection System 1D-10. . . . . . . .
Bleeding Air From The Oil
Injection System 1D-11. . . . . . . . . . . . . . . . . . . . .
Adjusting The Oil Injection Pump 1D-11. . . . . .
Propeller Installation 1D-11. . . . . . . . . . . . . . . . . . . .
Tilt Pin Adjustment 1D-12. . . . . . . . . . . . . . . . . . . . .
Trim Tab Adjustment 1D-13. . . . . . . . . . . . . . . . . . . .