Mesto FERROX PLUS Series - Liquid flows out of the pump; Nozzle does not spray; Safety valves blow off too early; Shut-off valve does not close

10
18
GB IRL AUS USA NZ CDN IND
&RQWDFWDGGUHVVIRUDGGLWLRQDOLQIRUPDWLRQĺVHHWLWOHSDJH.
Warranty
:HJXDUDQWHHWKDWIURPWKHWLPHLWLV¿UVWSXUFKDVHGIRUDSHULRGRIWKHOHJDOO\YDOLGUHTXLUHGZDUUDQW\
SHULRGPD[LPXP\HDUVWKLVGHYLFHZLOOQRWH[KLELWDQ\PDWHULDORUSURFHVVLQJHUURUV,IGHIHFWVDUH
discovered during the warranty period, MESTO or the distributor in your country will repair the device
ZLWKRXWFKDUJLQJIRUWKHODERURUPDWHULDORUDWWKHGLVFUHWLRQRI0(672UHSODFHWKHGHYLFHLWVHOIRULWV
defective parts.
If such defects are discovered, please contact us immediately. We require the invoice or cash register
receipt for purchase of the device.
7KHZDUUDQW\GRHVQRWLQFOXGHZHDULQJSDUWVVHDOV2ULQJVGLDSKUDJPHWFRUGHIHFWVZKLFKKDYH
occurred due to improper use or unforeseeable circumstances.
Fault Cause Remedy
/LTXLGÀRZVRXWRIWKHSXPS Valve disk [23] dirty of
defective.
Clean or replace the valve disk.
)LJ.
The nozzle does not spray
even though pressure is
present.
Filter [22] and / or nozzle
[21] blocked.
&OHDQWKH¿OWHURUDQGQR]]OH)LJ
.
Safety valves blows off too
early.
Safety valve [12] is defec-
tive.
5HSODFHVDIHW\YDOYH)LJ
The shut-off valve does not
close.
Liquid emerges without the
lever being activated.
O-ring [24] on the pressure
bolt not greased.
Defective pressure bolt [25]
or O-ring [24].
Grease the O-ring of the pressure
EROW)LJ5HSODFHWKHSUHVVXUH
bolt or O-ring. )LJ.
Pressure gage is not indicating
any tank pressure.
Pressure gage [16] defec-
tive.
Sever attachments (at top, at bottom,
RQULJKW>@)LJ Open panel
[27], unscrew pressure gage [16] with
wrench and replace. )LJ
,QVHUW¿[LQJNQRE>@IURPWKHVSDUH
SDUWVSRXFK>@SXVKWRWKHULJKWDQG
insert panel [27]. )LJ.
CE Declaration of Conformity
according to EC Machinery Directive 2006/42/EC, Appendix II, No. 1A.
We,
MESTO Spritzenfabrik Ernst Stockburger GmbH
Ludwigsburger Straße 71
D-71691 Freiberg
declare under our sole responsibility that the products high-pressure spraying devices of the series
3565, 3585, 3595, 3615 from factory number 1289536 in the version supplied comply with all relevant
provisions of the Directive 2006/42/EC. Furthermore, the device complies with the Directive 97/23/EC
for pressure equipment.
Rolf Rehkugler, Ludwigsburger Str. 71, D- 71691 Freiberg, is authorized to compile the technical
documentation.
Freiberg, 15.12.2011
Bernd Stockburger - Managing Director –