Mitsubishi MT160D Instruction Book

SERIAL NUMBERS
Tractor serial number
It is located at the right side of the transmission case
specifically
upper side (under HST filter).
NOTES, CAUTIONS and WARNINGS
~".
~----1 :z
Engine serial number
It is located at the right hand side of the cylinder
block, specifically injection pump side.
NOTES, CAUTIONS and WARNINGS are used in this manual to emphasize important and critical
instructions. They are used for
the following conditions:
NOTE . .............. An operating procedure, condition, etc., which is essential to highlight.
A CAUTION . ....... Operating procedu res, practices, etc., wh ich if not strictly observed, will
resu It in damage to or destruction of machine.
A WARNING . ...... Operating procedures, practices, etc., which if not correctly followed, will
result
in personal injury or loss of life.
TREATMENT OF A NEW TRACTOR
All components of your tractor are subject to stringent
checking during assembly in the factory. However, a new
tractor should be carefully checked over by the operator
himself. For the first- 25 ~ 50 hours operation, heavy duty
work should be avoided. If heavy duty work is unavoidable,
drive in a gear one stage lower than you would normally
use, and run the engine at lower rpm.
"1M PORTANT"
50-HOUR SERVICE
,
When the tractor is brand new, after the first 50 hours
running, the following service, maintenance and checking
should be carried out by th is instruction book.
1. Replace the engine oil filter and engine oil.
2. Replace
the transmission oil.
3. Retighten all bolts and nuts, paying special attention to
those for steering linkage and wheel.
4. Check and adjust the fan belt tension.
5. Check the wheels to see if their condition is good and
tire pressure is correct.
6. Retighten the cylinder head bolts and adjust valve
clearances.
7. Front axle diff. case and gear case oil replacement of
4-wheel drive tractor.
8. Cooling water replacement.
9. Air cleaner element cleaning.
10. Clean
the fuel filter.
11.
Check the front hub for end-play.
12. Check the battery electrolyte.
13. Clean the hydraulic oil filter.
This
50-hour Service is an essential procedure for keeping
the tractor in top condition, so it must be done properly.

Mitsubishi MT160D Specifications

General

Brand	Mitsubishi
Model	MT160D
Category	Tractor
Language	English