MOTO GUZZI NORGE 1200 User Manual

use and maintenance Norge 1200
4
TABLE OF CONTENTS
SAFETY WARNINGS ..................................... 2
TECHNICAL INFORMATION ......................... 2
WARNINGS - PRECAUTIONS - GENERAL
ADVICE ......................................................... 2
TABLE OF CONTENTS ......................................... 4
BASIC SAFETY RULES......................................... 6
CLOTHING ............................................................. 9
ACCESSORIES ................................................... 10
LOAD.................................................................... 10
POSITION OF KEY COMPONENTS - KEY ... 12
LOCATION OF INSTRUMENTS/CONTROLS 14
INSTRUMENTS AND INDICATORS............. 15
INSTRUMENTS AND INDICATORS TABLE ....... 16
MULTIFUNCTION LCD DISPLAY........................ 18
LOCATION OF ACCESSORIES (if any)........ 25
ACCESSORIES (if any)................................ 26
MAIN INDEPENDENT CONTROLS .............. 27
CONTROLS ON LEFT HANDLEBAR .................. 27
CONTROLS ON RIGHT HANDLEBAR................ 27
CONTROLS ON THE DASH PANEL ................... 28
IGNITION SWITCH .............................................. 29
STEERING LOCK ................................................ 29
PARKING LIGHTS ............................................... 30
AUXILIARY EQUIPMENT ............................ 31
UNLOCKING/LOCKING THE SEAT .................... 31
GLOVE/TOOL KIT COMPARTMENTS ................ 31
LUGGAGE ANCHOR POINTS............................. 32
WINDSCREEN ADJUSTMENT............................ 33
MAIN COMPONENTS .................................. 34
FUEL .................................................................... 34
BRAKE FLUID - RECOMMENDATIONS ............. 35
DISC BRAKES ..................................................... 36
FRONT BRAKE.................................................... 37
REAR BRAKE ...................................................... 38
TOPPING UP ....................................................... 38
ABS ...................................................................... 39
CLUTCH FLUID - RECOMMENDATIONS........... 41
CLUTCH ............................................................... 42
TYRES ................................................................. 43
ENGINE OIL......................................................... 45
ADJUSTING THE FRONT BRAKE LEVER AND
THE CLUTCH LEVER .......................................... 45
CATALYTIC SILENCER ...................................... 46
EXHAUST MUFFLER/EXHAUST SILENCER...... 46
OUTER STRUCTURES ................................ 47
REMOVING THE REAR LEFT SIDE BODY
PANEL.................................................................. 47
REMOVING THE RIGHT SIDE BODY PANEL .... 47
REMOVING THE LUG ......................................... 47
REMOVING THE LEFT SIDE BODY PANEL....... 48
LIFTING THE DASH PANEL................................ 48
INSTRUCTIONS FOR USE .......................... 49
GETTING ON AND OFF THE VEHICLE.............. 49
PRE-RIDE CHECKS ............................................ 51
PRE-RIDE CHECKS CHART ............................... 52
STARTING ........................................................... 53
MOVING OFF AND RIDING................................. 55
RUNNING-IN ........................................................ 58
STOPPING ........................................................... 59
PARKING ............................................................. 59
PUTTING THE VEHICLE ON THE STAND ......... 60
SUGGESTIONS TO PREVENT THEFT............... 62
MAINTENANCE........................................... 62
SCHEDULED MAINTENANCE CHART............... 63
IDENTIFICATION DATA ...................................... 66
JOINTS WITH SCREW CLAMPS ........................ 66
CHECKING AND TOPPING UP ENGINE OIL
LEVEL .................................................................. 67
CHANGING ENGINE OIL AND OIL FILTER........ 68
FRONT WHEEL ................................................... 69
REAR WHEEL...................................................... 70
FRONT BRAKE CALLIPER.................................. 70
CHECKING THE CARDAN SHAFT OIL LEVEL . 71
CHECKING GEARBOX FLUID LEVEL ................ 71
REAR-VIEW MIRRORS ....................................... 72
INSPECTING THE FRONT AND REAR
SUSPENSIONS.................................................... 73
FRONT SUSPENSION......................................... 73
REAR SUSPENSION ........................................... 74
CHECKING THE BRAKE PADS FOR WEAR ...... 76
ADJUSTING THE THROTTLE CONTROL .......... 77
SPARK PLUGS .................................................... 77
CHECKING THE STAND ..................................... 79
BATTERY ............................................................. 81
LONG INACTIVITY OF THE BATTERY ............... 81
CHECKING AND CLEANING THE TERMINALS . 81
REMOVING THE BATTERY ................................ 82
CHECKING BATTERY FLUID LEVEL.................. 83
CHARGING THE BATTERY................................. 83
INSTALLING THE BATTERY ............................... 84
CHECKING THE SWITCHES............................... 84
CHANGING THE FUSES ..................................... 85
BEAM SETTING................................................... 87
BULBS .................................................................. 88
CHANGING THE HEADLIGHT BULBS................ 89
CHANGING THE FRONT AND REAR TURN
INDICATOR BULBS ............................................. 90
CHANGING THE TAIL LIGHT BULB.................... 91
REPLACING THE NUMBER PLATE BULB ......... 91
TRANSPORT............................................... 92
DRAINING THE FUEL TANK ............................... 92
CLEANING .................................................. 93
LONG PERIODS OF INACTIVITY........................ 94
TECHNICAL DATA...................................... 96
LUBRICANT CHART ............................................ 99
AUTHORISED DEALERS AND SERVICE
CENTRES........................................................... 103
GUZum_norge1200#06_###e.book Page 4 Saturday, May 27, 2006 12:55 PM

MOTO GUZZI NORGE 1200 Specifications

General

Engine Type	90° V-twin, 4-stroke
Displacement	1151 cc
Bore x Stroke	95 mm x 81.2 mm
Transmission	6-speed
Fuel System	Electronic fuel injection
Final Drive	Shaft drive
Front Brakes	Dual 320 mm discs, 4-piston calipers
Rear Brakes	Single 282 mm disc, 2-piston caliper
Seat Height	800 mm
Cooling System	Air
Maximum Power	102 HP (75 kW) @ 7, 000 rpm
Maximum Torque	104 Nm @ 5, 500 rpm
Front Suspension	Telescopic forks
Rear Suspension	Single shock, adjustable preload
Fuel Capacity	23 liters