MAINTENANCE
The warranty on this lawn tractor does not cover items that
have been subjected to operator abuse or negligence. To
receive full value from the warranty, operator must maintain
lawn tractor as instructed in this manual. The following IVlaln-
tsnance Check List issupplied to assist operator to properly
maintain lawn tractor. This is a check list only.
Adjustments referred to will be found in Adjustments section
of this manual.
BEFORE STORAGE
BEGINNING EACH SEASON
EVERY 100 HOURS
EVERY 50 HOURS
EVERY 25 HOURS
MONTHLY
FREQUENTLY
AFTER FIRST 5 HOURS
BEFORE EACH USE
Check Engine Oil Level
Change Engine Oil
Change Oil Filter (if so equipped)
Clean Air Fitter
Change Spark Plug(s)
Replace Air Filter Paper Cartridge
Clean Air Screen
Inspect Muffler/Spark Arrestor
Rep[ace Fuel Filter
Check Battery Fluid Level/Recharge (if so _qui_ped)
Clean Battery and Terminals
Adjust Motion Drive Belt Tension
Check Brake Operat on • •
Check Transmission Cooling
Check Tire Pressure (10-14 Ibs) • •
Adjust Mower Deck Belt
Sharpen or Replace Mower Blades
Check for Loose Fasteners •
Clean Lawn Tractor •
See Lubrication Chart !
MAINTENANCE CHECK LIST
SERVICE RECORD
FILL IN DATES
AS YOU COMPLETE
REGULAR SERVICE
NOTES: 1. Change more often when operating under a heavy load or in HIGH temperatures. (90°and above)
2. Service more often when operating in dirty or dusty conditions. 3. Replace more often when mowing in sandy soil.
At no time dur ing maintenance or adjustments
can the lawn tractor be lifted more than 20
inches from level position without taking the
_ following precautions:
1. Remove gasoline from tank and run engine
until carburetor is dry.
2. Remove battery. (see BATTERY REMOVAL
paragraph in MAINTENANCE section.)
3. Remove oll from crankcase.
LUBRICATION
For lubrication frequency see Maintenance Check List. For
lubrication points and type of lubricant see Lubrication
Chart. The transmission has been lubricated for life.
18
To Next Page
Loading...
Need help?
General
