Nordyne MMHB-056A AA FC-02 User Manual

Thank you for visiting HVACmanuals.com. Whether its residential, commercial
or mobile homes, we’re your HVAC info source. If you are searching for
information regarding a specific HVAC unit or part, please e-mail us your request
at info@HVACmanuals.com. If we don’t have the information, we can put it on
our search list.
Some of the info we offer in our downloads can be quite old. It’s rare that prices
for parts are listed in manuals, but if you see any please ignore them as the
prices are probably obsolete.
Most manuals contain parts lists and diagrams. The older the unit, the more
you’ll find obsolete parts. In same cases the parts may still be available, but
under a new part number. In other cases a generic part may be suitable for use.
For help in finding parts, please visit our parts store at
www.HVACpartstore.com.
Please note that specifications and illustrations are subject to change without notice and without
incurring obligations.
The information contained in this download is for the use of qualified individuals who have been
trained to interpret this data. All repairs on HVAC equipment should be performed by a qualified
technician. In some states, counties or cities, the law states that repairs must only be done by
licensed individuals. Persons not legally or technically qualified should not attempt to interpret
this information or perform any repairs
.

Nordyne MMHB-056A AA FC-02 Specifications

General

Brand	Nordyne
Model	MMHB-056A AA FC-02
Category	Furnace
Language	English

Summary

LIMITED WARRANTY

WARRANTY TERMS AND LIMITATIONS

Defines warranty scope, exclusions, and coverage periods for parts and labor.

INSTALLATION GUIDANCE

INSTALLER NOTICES

Important advisories for installers regarding safety, performance, and warranty.

INSTALLATION REQUIREMENTS

UNIT LOCATION AND CLEARANCES

VENTING AND DUCTING INSTALLATION

GENERAL INSTALLATION PROCEDURES

CUTOUTS AND OPENINGS

Instructions for creating floor, fuel line, ceiling, and roof openings.

COMPONENT INSTALLATION

Steps for installing duct connectors, mounting plates, furnace, and roof jacks.

TRANSIT-MODE VENTING INSTALLATION

ELECTRICAL AND FUEL SYSTEMS

ELECTRICAL WIRING CONNECTIONS

Instructions for connecting power supply and thermostat wiring.

FUEL PIPING REQUIREMENTS

Guidelines for sizing and installing gas and oil fuel lines.

LIGHTING AND FURNACE OPERATION

SAFETY AND PRE-LIGHTING CHECKS

Critical safety warnings and pre-operation checks before lighting the furnace.

STANDING PILOT MODELS OPERATION

Procedures for lighting and operating standing pilot furnace models.

DIRECT IGNITION MODELS OPERATION

Operating instructions and sequence for direct ignition furnace models.

GAS/OIL GUN FURNACE OPERATION

Operating instructions and sequence for gas and oil gun furnace models.

FURNACE CONTROLS AND FUNCTIONS

FURNACE CONTROL COMPONENTS OVERVIEW

SERVICE GUIDE

BURNER ADJUSTMENTS AND SETTINGS

TROUBLESHOOTING STANDING PILOT MODELS

MAIN BURNER OPERATION ISSUES

Diagnosing problems with main burner ignition or flame.

PILOT AND GAS VALVE ISSUES

Troubleshooting pilot light failure and gas valve malfunctions.

TROUBLESHOOTING DIRECT IGNITION MODELS

BURNER MOTOR AND IGNITION PROBLEMS

BLOWER AND CONTROL MODULE ISSUES

FLAME LOCKOUT AND SHORT CYCLING

INSUFFICIENT HEAT AND BURNER OPERATION

MAINTENANCE

SERVICEMAN MAINTENANCE TASKS

WIRING DIAGRAMS

GAS FURNACE WIRING DIAGRAMS

STANDING PILOT W/INDUCED DRAFT FURNACE DIAGRAMS