Nortec RESDELUX - Table of Contents

Table Of Contents
INSTALLATION 1
RECEIVING & UNPACKING EQUIPMENT ................................1
PRE-INSTALLATION CHECKPOINT ...................................1
HUMIDIFIER CONFIGURATION......................................1
LOCATION & MOUNTING .........................................1
HUMIDIFIERS .............................................1
STEAM DISTRIBUTOR NOZZLE (in duct location) ..........................2
STEAM HOSE INSTALLATION.....................................3
CONDENSATE HOSE (supplied)....................................3
BLOWER PACK CONNECTION ....................................3
CABINET MOUNTING THE BLOWER PACK ............................3
REMOTE MOUNTING THE BLOWER PACK ............................4
PLUMBING .................................................5
WATER SUPPLY LINE .........................................5
DRAIN LINE...............................................5
ELECTRICAL................................................6
ELECTRICAL REQUIREMENTS FOR PERMANENTLY CONNECTED RESDELUX .........6
ELECTRICAL REQUIREMENTS FOR THE CORD CONNECTED MODEL RESDELUX/C ......6
LOW VOLTAGE CONTROL WIRING AND INSTALLATION ......................6
CONTROL WIRING ........................................6
CONTROL INSTALLATION ....................................7
OPERATION 7
INTRODUCTION ..............................................7
RESDELUX OPERATION .........................................7
MANUAL CAPACITY ADJUSTMENT .................................8
OTHER POTENTIOMETERS .....................................8
MAINTENANCE 8
STEAM CYLINDER ............................................8
WHEN TO REPLACE THE STEAM CYLINDER ............................8
HOW TO REMOVE THE STEAM CYLINDER .............................9
HOW TO INSTALL THE REPLACEMENT CYLINDER ........................9
MANDATORY CLEANING OF THE DRAIN VALVE ...........................10
EXTENDED SHUTDOWN ........................................10
TROUBLESHOOTING 11
DIAGNOSTIC PROCEDURES - TROUBLESHOOTING .........................11
PROCEDURES AND TERMS USED IN DIAGNOSING .........................12