Odyssey PC680 - Maintenance

MAINTENANCE
ODYSSEY
®
batteries are very different from standard liquid-acid batteries that are
openly vented. The ODYSSEY battery is and operates as a sealed battery, recycling
nearly all gases internally under normal operating conditions. There is no corrosion
of the positive terminal or corrosion to the surrounding area. ODYSSEY batteries
are shipped fully charged from the factory, but prior to installation, check the battery’s
voltage to see if it is 12.65V or greater. If not, recharge it using the procedure below.
Do not charge in an air tight compartment.
Never attempt to remove the top decal cover, as it will cause the battery to fail.
CHARGING
The SOC in an ODYSSEY battery can be determined from the following chart:
ODYSSEY
®
PERFORMANCE SERIES
™
BATTERIES
Model
Voltage
PHCA**
(5 sec)
CCA* HCA MCA
Nominal Capacity
Reserve
Capacity
Minutes
Length
inches
(mm)
Width
inches
(mm)
Height
inches
(mm)
Weight
lbs
(kg)
Terminal
Torque
Specs in-lbs
(Nm max)
Internal
Resistance
(m
Ω )
Short
Circuit
Current
(20 Hr
Rate-Ah)
(10 Hr
Rate-Ah)
75/86-705
12 1100 708 875 760 49 45 89
9.46
(240.3)
7.01
(178.1)
7.98
(202.7)
43.4
(19.7)
SAE, Side 3/8-16
"
Receptacle
60
(6.8)
side only
2.8 2200
48-720 12 1250 723 950 842 69 63 130
10.91
(277.1)
6.89
(174.2)
7.5
(190.5)
48
(21.8)
SAE
N/A
2.8 2300
34-790
12 1500 792 1200 990 61 57 124
10.85
(275.6)
6.78
(172.2)
7.91
(200.9)
46.6
(21.1)
SAE
N/A
2.9 2400
34R-790 12 1500 792 1200 990 61 57 124
10.85
(275.6)
6.78
(172.2)
7.91
(200.9)
46.6
(21.1)
SAE
N/A
2.9 2400
34M-790
12
1500 792 1200 990 61 57 124
10.85
(275.6)
6.78
(172.2)
7.93
(201.4)
47.6
(21.6)
SAE and 3/8-16
"
Stud (Pos.), 5/16-
18
" Stud (Neg.)
60
(6.8)
studs only
2.9 2400
78-790
12 1500 792 1200 990 61 57 124
10.85
(275.6)
7.00
(177.8)
7.4
(188.0)
47.1
(21.4)
Side 3/8-16
"
Receptacle
60
(6.8)
2.9 2400
65-760
12 1500 762 1200 891 64 59 129
11.86
(301.2)
7.19
(182.6)
7.38
(187.5)
49.8
(22.6)
SAE N/A 2.3 2500
31-800 12 1600 802 1380 1188 99 94 188
13.0
(330.2)
6.79
(172.5)
9.42
(239.3)
69.0
(31.3)
SAE or 3/8-16" Stud
200
(200.6)
studs only
2.6 2600
31M-800
12 1600 800 1380 1200 99 94 188
13.0
(330.2)
6.79
(172.5)
9.46
(240.3)
69.3
(31.4)
SAE and 3/8-16
"
Stud (Pos.), 5/16-
18
" Stud (Neg.)
60
(6.8)
studs only
2.6 2600
8
Publication No. 2602-0232, Rev AA - September 2016 www.odysseybattery.com
Voltmeter Reading State of Charge
12.84 Volts or higher 100%
12.50 Volts 75%
12.18 Volts 50%
11.88 Volts 25%
*Cold Start Performance S.A.E. J537 June 82
** Pulse Current