User manual
If the methods above don't work, please contact the distributors and refer to the
warranty policy.
Do not drop or place the light on sand in case iron sand stick or go into switch
section or screw thread.
Tighten all the connections of the light before going underwater.
Please take out the batteries after each diving.
Please don't disassemble the sealed head, doing so may cause damage to
the flashlight and will void the warranty.
We recommend the use of high quality batteries. If the flashlight will not be
used for a long time, remove the batteries to avoid damage from electrolyte
leakage or battery explosion.
Please replace the O-rings if they are damaged after prolonged use and
regularly lubricate the o-rings with silicon grease so as to not erode the
rubber. Doing so will keep the flashlight properly sealed against water.
Please clean the contacts of your light from time to time, especially when the
light flickers or doesn’t light up. There are probably several reasons for a
flickering or not working light:
Reason A: The batteries need to be replaced.
Solution: Replace batteries (Please confirm correct installation of + and -
terminals).
Reason B: The threads, PCB board contact or other contacts are dirty.
Solution: Clean the contact points with an alcohol soaked cotton swab.
Tel:+86-755-33560383 Fax:+86-755-29454989
Email: info@orcatorch.com www.orcatorch.com
Address: 7F, Building 6, Rundongsheng Industrial Park,
Gushu, Xixiang, Baoan, Shenzhen, China (518102)
ORCATORCH TECHNOLOGY LIMITED
USAGE AND MAINTENANCE
Please clean the surface of the light with fresh water and wipe it dry after use
in case of the seawater corrosiveness.
PRODUCT INTRODUCTION
OrcaTorch D530 is a must-have primary dive light for divers.It offers 6 different
color options, Cold white, Neutral white, Red, Blue, UV and Green. The light uses
a titanium alloy side switch that offers 2 lighting modes, which allows for easy
operation underwater. The LED indicator light located on the switch button also
lets you know the battery's remaining charge.
We will replace products afflicted with manufacturing defects within 30 days of
purchase and repair a light free of charge within 12 months of purchase if
problems develop under normal use; if repair is required after 12 months from
the date of purchase, we will charge for parts. The total repair fee is dictated by
the cost of the replaced materials.
PRODUCT WARRANTY
Warning
The flashlight is high intensity lighting device and capable of causing eye
damage, please avoid shining the light directly into the eyes.
Please register your OrcaTorch products through official website
www.orcatorch.com to get extra 1 year warranty.
OPERATION INSTRUCTIONS
1.Modes Selection
Press side button to change among high, low, off.
2.Battery indicator:When the light is turned on, the battery indicator will be
on to show the battery level.
-Green: over 70%
-Orange: 30%-70%
-Red: 10%-30%
-Flashing red: less than 10%
3.Safe lock function:
Hold on the side switch for 5 seconds,the light will turn off and turn into a state of
safe lock.The side switch will be useless unless unlocking it by a double press.
(The light will flicker twice when you lock or unlock the switch,the battery
indicator will be green when at state of locked.)
4.Intelligent Over-Heat protection:
This torch is specially designed for underwater use. When used on land for too
long, it might get too hot. But this torch would drop down its output automatically
once its temperature reaches 65°to avoid damage to the light due to overheat.
5.The total runtime will be extended significantly if the light is used
discontinuously.
Notice: Stated data has been measured according to the international flashlight test
standards ANSI/NEMA FL1 using one OrcaTorch 18650 Li-ion battery (3.7V,
3400mah) under laboratory conditions. The parameters are approximate and may
vary between flashlights, batteries, and environments.
www.orcatorch.com
D530 Cold White
TECHNICAL PARAMETERS
Waterproof
Working voltage
Dimension
Net weight
Accessories
3-4.2 V
142mm(Length) x 25.5mm(Diameter) x 35.5mm(Head)
150g（excluding battery）
One USB rechargeable 18650 Li-ion battery,
micro USB cable, lanyard, O-rings
Runtime
Impact
Resistant
1.5m
under water 150m
2h50min
Output
Low
HighModel
Cold White
Neutral White
Red
Blue
UV
Green
Low
High
210 lumens
ANSI/NEMA FL1
80 lumens
6h10min
1h25min1300 lumens 380 lumens 4h30min
1h20min1200 lumens 500 lumens 2h50min
3h10min65 lumens 30 lumens 8h5min
3h30min8 lumens 3 lumens 6h10min
3h5min280 lumens 140 lumens 8h5min
PRODUCT FEATURES
Use 1*18650 Li-ion rechargeable battery
White light beam angle 8°， Red, Blue, UV, Green beam angle 6°
Cold white with max 1300 lumens for primary dive light
Red light offers two light modes for night dives to shoot shy animals
Blue light works with the yellow filter for marine fluorescence dives and research
UV 395 light works directly for fluorescent night diving
Easy operation with side titanium alloy button switch
Battery indicator
Safe lock function, prevents mis-operation
Intelligent Over-Heat protection and Over-discharge protection function
Water pressure resistant construction ,depth rated to 150 meters
Reverse polarity protection, to protect from improper battery installation
Constructed from high-strength A6061-T6 aluminum
Mil-Spec Type III hard anodized finish for durability and corrosion resistance
Two sides coated toughened glass with high water pressure resistance under
deep water
BATTERY REPLACEMENT
1.As shown in the figure, insert the battery with the anode side (+) toward the
light head.
2.Please do not reverse battery to avoid damage to the flashlight and battery.
3.Please do not use battery with higher voltage than flashlight working voltage.
4.Please do not use battery with damaged surface or deformation to avoid short
circuit, explosion, leakage, etc.
D530 Neutral White
D530 Red
D530 Blue
D530 UV
D530 Green
To Next Page
Need help?
General
