21
Consumable parts
List of Motor Maintenance Cycle / List of Replacement Parts
List of Motor Maintenance Cycle
Name of parts Model
KRF70 KRF110
Motor
Three-phase
200V spec.
Parts no. 0A001675000 0A001676000
Model
Toshiba IK-FCKA21
2.2kW 6P
Toshiba IK-FCKA21
3.7kW 6P
Qty. 1
※
Maintenance cycle 20,000Hr
Motor
Three-phase
400V spec.
Parts no. 0A001677000 0A001678000
Model
Toshiba IK-FCKA21
2.2kW 6P
Toshiba IK-FCKA21
3.7kW 6P
Qty. 1
※
Maintenance cycle 20,000Hr
※Time on the list is the time that possibility to reaching the friction damage range becomes high. It is
not necessary to replace the motor on time because it differs depending on the installation site.
However, be sure to replace and repair the motor whenever troubles happen.
List of Replacement Parts
(Parts to be replaced periodically at specified period.)
(V,B, or VB enters into the □)
Name of parts Model KRF70-
□
KRF-
□
H KRF110-
□
Vane
Parts Number
04101504010 04101504010 04100653010
Quantity /unit 6 6 6
Replace-ment time
10,000 6,000 5,500
Bearing
Parts Number 0A000332000 0A000332000 0A000333000
Quantity /unit 2 2 2
Replace-ment time
10,000 6,000 5,500
※Consider the replacement time as a guide, and carry out the periodic replacement.
※Advanced technologies are required to replace vanes and bearings, so contact with our dealer or
service personnel.
※Exchange bearings at the same time when you exchange vanes.
※The indicated blade replacement period is recommended in order to help prevent breakdown due to
blade wear, and assumes average blade wear at 60Hz operation; specific performance is not
guaranteed. The blade might not last as long as the above specified replacement time due to higher
than normal wear from operating environments with low humidity or high temperatures, etc.
The blade should be replaced soon if performance decreases or noise levels increase.
※If the blade is not replaced periodically, progressive wearing down of the the blade height and
thickness can result in the blade being damaged which could lead to the pump becoming inoperable.
To Next Page
Loading...