Oshkosh JLG X600AJ - User Manual

To Next Page

Operation and Safety Manual

ANSI

Original Instructions - Keep this manual with the machine at all times.

Model(s)

X600AJ

3121637

June 29, 2018 - Rev F

To order go to Discount-Equipment.com

Main Page

Safety Alert Symbols and Safety Signal Words5
Contact6
In USA6
Outside USA6
Revision Log7
Table of Contents8
Section - Paragraph, Subject Page10
Section 1 - Safety Precautions14
General14
Pre-Operation14
Operator Training and Knowledge14
Workplace Inspection15
Machine Inspection16
Operation16
General16
Trip and Fall Hazards17
Electrocution Hazards18
Minimum Approach Distances (M.A.D.)19
Tipping Hazards20
Crushing and Collision Hazards22
Towing, Lifting, and Hauling23
Maintenance23
Maintenance Hazards23
Battery Hazards25
Section 2 - Preparation and Inspection27
2.1 Personnel Training27
Operator Training27
Training Supervision27
Operator Responsibility27
Maintenance28
Pre-Start Inspection30
Daily Walk-Around Inspection32
General32
Daily Walk-Around Inspection33
Function Check34
Skyguard™ Sensor and Override Switch35
Location35
Skyguard™ Sensor and Override35
Section 3 - Machine Controls, Indicators and Operation37
Basic Machine Nomenclature37
Ground Control Station39
Ground Control Station - with Enable Lever39
Ground Control Station - with Enable Lever40
Ground Control Station - with Enable Lever42
Ground Control Station - with Enable Knob43
Ground Control Station - with Enable Knob45
Platform/Remote Control Station46
Maintenance Control Position on the46
Platform/Remote Control Position from the Ground47
Platform/Remote Control Station51
Machine53
Section 4 - Machine Operation60
Description60
Boom Operating Characteristics and60
Limitations60
Capacities60
Stability60
Engine Operation61
Gas Engine Starting Procedure61
Ground/Emergency Control Box61
Gas Engine Shutdown Procedure62
Ground/Emergency Control Box62
AC Voltage Machine63
LITHIUM-ION Machine64
Ground/Emergency Control Box64
Base and Boom/Jib Alignment65
Tracks - Driving, Steering and Track Width Adjust66
Travelling (Drive and Steer)66
Travelling (Grades and Side Slopes)66
Grade and Side Slope Definition68
Jib Position for Travelling69
Outrigger Operation70
Setting Outriggers from the Platform/Remote Console72
Retracting the Outriggers73
Boom/Platform Operation74
Overload Alarm74
Engine Pre-Heat74
Platform Level Adjustment74
Platform/Remote Control Box75
Raise and Lower the Tower Boom76
Raise and Lower the Main Boom76
Telescope the Main Boom76
Platform Rotation76
Raise and Lower the Jib76
Swinging the Boom76
Platform - Load/Reach Chart - X600AJ77
Skyguard Operation (if Equipped)78
Skyguard™ Function Table78
Platform Removal/Installation79
Battery Charging - Gas/Ac-Electric80
Battery Charging - Daily80
4.10 Battery Charging - Lithium-Ion Machine81
Charging the Battery Pack81
Charge Curve83
4.11 Shut down and Park84
4.12 Lifting and Tie down85
Lifting - Outrigger Lifting Rings85
Lifting Machine - Lifting Lugs Location86
Lifting Machine - Lifting Bar Rigging87
Lifting - Fork Lift Pockets88
Lifting Machine - Fork Lift Pockets Location88
Loading and Unloading the Machine on Transport Vehicles Using Ramps89
Tie down90
4.13 Machine Decals92
Decal Installation - Standard - Left Side92
Decal Installation - Standard - Right Side93
Decal Installation - Lithium-Ion - Left Side97
Decal Installation - Lithium-Ion - Right Side98
X600AJ - Decal Installation - Lithium99
Section 5 - Emergency Procedures101
General101
Incident Notification101
Emergency Operation101
Power Main Cut-Off Switch Location101
Operator Unable to Control Machine102
Platform or Boom Caught Overhead102
Ground Control Station105
Ground Control Station106
Ground Component Valves - Outriggers113
Operating Specifications119
Dimensional Data119
Chassis Data120
Capacities120
Engine Data121
Lithium Ion Specifications121
Service & Maintenance123
Lubrication and Maintenance Point123
Hydraulic Oil Specifications124
Hydraulic Oil Specifications125
Component Maintenance Intervals127
Component Maintenance Intervals - X600AJ - Lithium-Ion Machine128
Worn Parts133
Electric Motor Maintenance136
Power Supply Terminals136
Menu Input138
Lithium Ion150
Example of Lithium-Ion Battery Pack151
Battery Charger Fault Codes157
Procedure for Handling Hot Cells159
Procedure for Handling Vented Cells160
Procedure for Exploded Cells162
Lithium Battery Fire163

Need help?

Do you have a question about the Oshkosh JLG X600AJ and is the answer not in the manual?

Oshkosh JLG X600AJ Specifications

General

Brand	Oshkosh
Model	JLG X600AJ
Category	Boom Lifts
Language	English

Related product manuals

Oshkosh JLG X600AJ - User Manual

Table of Contents

Oshkosh JLG X600AJ Specifications

Related product manuals