Ozone Ozium 2 - Care and Maintenance; Inspection; Replacing the Pod

CARE AND MAINTENANCE
EN
18
17
TheOzium2willlastyoumanyightsandmanyyearsiflookedaftercorrectly.Tokeepyourharnesscleanandairworthy,pleasenotethe
following:
•AvoidexcessiveexposuretoUV,heatandhumidity.
•Packtheharnessdryandstoreinacooldryplace.
•Neverdragyourharness.
•Keepyouharnesscleanofdirt,oilsandanycorrosivesubstance.
•Usewaterandaclothtoclean.
INSPECTION
Forsafety,routineinspectionofallofyourequipmentisvitallyimportant.Ozonerecommendsaserviceintervalof12monthsinaddition
totheusualpreightchecks.
Forinspection,visuallycheckthestitching,webbingandallstructurallyimportantareas.Payparticularattentiontothewebbingaroundthe
hangpointareaunderthecarabiner,asthisiswhereabrasionismostlikely.
Ifyoundanydamageorifyouareinanydoubtmakesuretheharnesscheckedbyaprofessional.
REPLACING THE POD
ReplacementpodsareavailablefromyourOzonedealer.Itispossibleaftermanyhoursofuse,orafteranincidentresultingindamagethat
thepodrequireschanging.Toremovetheoldpod:
1. Disconnectthethinredpodloopsfromthecarabiners(donotconfusethesewiththemainhangpointloops).
2. Undobothzips(oneeachside).
3. TearthepodofftheVelcro.
4. Removethelonglinesthatrunthroughthepulleysonbothsidesofthepod.
5. Disconnectthethespeedbarfromthefootplateelastic.
Replacingthepodisthereversaloftheaboveprocedure.Usealarksfoottoconnectthepodlinesandmakesurethethinredpodloopsare
connectedtothecarabiner(step1).Ensuretousetheredloops,theshorterblueloopsareforattachingthepodtoanOzium(1)structure.
IMPORTANT: Ensure that the red pod loops (1) are attached to the carabiners. Failure to do so will put excessive
load through the zip causing failure.
3. Velcro
2. Zips
1. Red pod loops on carabiners
4. Purple pod lines
5. Speed bar attachment
IMPORTANT: Ensure the red
pod loops (1) are attached
to the carabiners. Failure
to do so will put excessive
load through the zip causing
failure.