Perkins 403EA-11 - Page 110

Engine Valve Lash - Check ............................. 96
Engine Warm-up ............................................. 47
F
Fan Clearance - Check ................................... 97
Four Cylinder Turbocharged........................ 97
Three Cylinder ............................................. 97
Features and Controls..................................... 35
Fire Prevention and Explosion Prevention...... 13
Ether ............................................................ 14
Fire Extinguisher.......................................... 14
Lines, Tubes, and Hoses ............................. 15
Fluid Recommendations ........................... 55, 57
ELC Cooling System Maintenance.............. 60
Engine Oil .................................................... 56
General Coolant Information ....................... 57
General Lubricant Information..................... 55
Fluid Recommendations (General Fuel
Information) ................................................... 62
Contamination Control Recommendations for
Fuels .......................................................... 70
Diesel Fuel Characteristics.......................... 66
Diesel Fuel Requirements ........................... 63
General Information..................................... 63
Foreword ........................................................... 4
California Proposition 65 Warning................. 4
Literature Information .................................... 4
Maintenance .................................................. 4
Maintenance Intervals ................................... 5
Operation ....................................................... 4
Overhaul ........................................................ 5
Safety............................................................. 4
Fuel and the Effect from Cold Weather ........... 52
Fuel Conservation Practices ........................... 47
Fuel Injector - Test/Change ............................. 97
Identification of a suspect Fuel Injector ....... 98
Fuel Related Components in Cold Weather ... 53
Fuel Filters ................................................... 53
Fuel Heaters ................................................ 53
Fuel Tanks ................................................... 53
Fuel Shutoff ..................................................... 42
Fuel System - Prime........................................ 98
Fuel System Filter - Replace......................... 100
Fuel Filter With Canister ............................ 100
Fuel System Primary Filter/Water
Separator - Drain ......................................... 101
Fuel Tank Water and Sediment - Drain ......... 102
Drain the Water and the Sediment ............ 102
Fuel Storage Tanks.................................... 102
Fuel Tank ................................................... 102
G
Gauges and Indicators .................................... 33
Indicator Lamps ........................................... 34
General Hazard Information.............................. 8
Containing Fluid Spillage............................. 10
Dispose of Waste Properly .......................... 12
Fluid Penetration ......................................... 10
Inhalation ......................................................11
Pressurized Air and Water............................. 9
Static Electricity Hazard when Fueling with
Ultra-low Sulfur Diesel Fuel ....................... 10
H
Hoses and Clamps - Inspect/Replace........... 102
Replace the Hoses and the Clamps.......... 103
I
Important Safety Information............................. 2
L
Lifting and Storage .......................................... 31
M
Maintenance Interval Schedule....................... 73
Commissioning ............................................ 73
Daily ............................................................. 73
Every 1000 Service Hours........................... 73
Every 1500 Service Hours........................... 73
Every 2000 Service Hours........................... 73
Every 250 Service Hours or 1 Year ............. 73
Every 250 Service Hours or 6 Months......... 73
Every 3000 Service Hours........................... 73
Every 3000 Service Hours or 2 Years ......... 73
Every 50 Service Hours or Weekly.............. 73
Every 500 Service Hours............................. 73
Every 500 Service Hours or 1 Year ............. 73
Every 6000 Service Hours........................... 73
When Required............................................ 73
Maintenance Log........................................... 108
Maintenance Recommendations .................... 71
Maintenance Records ................................... 107
Maintenance Section....................................... 54
Model View Illustrations .................................. 18
Industrial Engine Model Views .................... 18
Model Views .................................................... 18
Monitoring System (Engine Warning
Indicators)...................................................... 35
Mounting and Dismounting ............................. 15
110 M0132847
Index Section