Philips HTS9800W Service Manual

Published by TE 0608 AV Systems Printed in the Netherlands Subject to modification EN 3139 785 31510
HTS9800W/12/37/55
DVD Receiver
CLASS 1
LASER PRODUCT
1 Technical Specifications and Connection
Facilities 2
2 Measurements Setup, Service Aid &
Lead Free Requirements 5
3 Directions for use 10
4 Dismantling Instructions & Service Positions 14
5 Service Test Program 20
6 Block Diagram, Wiring Diagram 23
Block Diagram 23
Wiring Diagram 25
7 Circuit Diagram and PWB Layout 27
DVM 7.3 AV Board: Schematic 27
DVM 7.3 AV Board: Layout (Top View) 34
DVM 7.3 AV Board: Layout (Bottom View) 35
Front Display: Schematic 36
Front Display: Layout (Top View) 38
Front Display: Layout (Bottom View) 39
Front LED Panel: Schematic 40
Front LED Panel: Layout (Top View) 41
Front LED Top: Schematic 42
Front LED Top: Layout (Top View) 42
Front LED Top: Layout (Bottom View) 42
Front LED Bottom: Schematic 43
Front LED Bottom: Layout (Top View) 43
Front LED Bottom: Layout (Bottom View) 43
Interface Board: Schematic 44
Interface Board: Layout (Top View) 46
©
Copyright 2005 Philips Consumer Electronics B.V. Eindhoven, The Netherlands.
All rights reserved. No part of this publication may be reproduced, stored in
a retrieval system or transmitted, in any form or by any means, electronic,
mechanical, photocopying, or otherwise without the prior permission of Philips.
Version 1.0
Contents PageContents Page
Interface Board: Layout (Bottom View) 47
Mains Board: Schematic 48
Mains Board: Layout 49
Wireless Interface Board: Schematic 50
Wireless Interface Board: Layout (Top View) 53
Wireless Interface Board: Layout (Bottom View) 54
PCBA SOC: Schematic 55
PCBA SOC: Layout (Top View) 55
Spk Panel: Schematic 56
Spk Panel: Layout (Top View) 57
Spk Panel: Layout (Bottom View) 58
Junction Box: Schematic 59
Junction Box: Layout (Top View) 60
Junction Box: Layout (Bottom View) 61
UCD Module Dev. Schematic 62
UCD Module Dev. Layout (Top View) 64
UCD Module Dev. Layout (Bottom View) 65
VGA Conn Board Schematic & Layout 66
8 PSU - Main Unit and Wireless Box Surround 67
PSU - Main Unit (For Information Only) 68
PSU - Wireless Box Surround 69
9 Exploded View & Spare Parts List 70
Exploded View of the Main Unit Set 70
Exploded View of the Wireless Surround Box Set 71
Exploded View of the Power Box Set 72
Spare Parts List 75

Philips HTS9800W Specifications

Picture/Display

Aspect ratio	4:3, 16:9
D/A converter (Picture)	12 bit, 108 MHz
Picture enhancement	High Def (720p, 1080i), Video upscaling, Video upsampling

Sound

D/A converter (Sound)	24 bit, 192 kHz
Frequency response	30-50000 Hz
Signal to noise ratio	>95 dB
Output power (RMS)	3x125W (Front L/R/ Front Centre) + 2x85W (Rear L/R) + 105W (Rear Centre) + 150W (Subwoofer)
Total Sound Power (RMS)	800 W

Power

Power supply	220-240V, 50Hz
Standby power consumption	< 1 W
Power consumption	165 W

Loudspeakers

Satellite speaker freq range	120-50000 Hz
Satellite speaker impedance	6 ohm
Subwoofer freq range	30-120 Hz
Subwoofer impedance	4 ohm

Dimensions

Set dimensions (W x H x D)	273 x 284 x 144 mm
Set weight	2.8 kg
Subwoofer dimensions (W x H x D)	300 x 399 x 300 mm
Subwoofer Weight	12 kg