STEERING SYSTEM
STEERING INSPECTION
Each week, or before a long ride, check all steering system fasteners and
tighten if necessary.
SKI ALIGNMENT
WARNING
Improper ski alignment or adjustment may cause loss of steering control,
resulting in serious injury or death. Do not attempt to change the ski alignment
or camber adjustment. Your POLARIS dealer can perform this service.
If the steering feels heavy, or if the snowmobile seems to pull or dart to the side,
ski alignment may need adjustment. Refer to the service manual, or your dealer,
to perform this service.
SKI TOE SETTINGS
WARNING
Improper ski toe adjustment may cause loss of steering control, resulting in
serious injury or death. Do not attempt to change toe adjustment. Your
POLARIS dealer can perform this service.
The skis on your snowmobile are set with a small amount of toe-out at the
factory. You can inspect the toe setting by following the procedure below.
SKI TOE MEASUREMENT TABLE
Model Skis Off Ground (Yes/
No)
Difference Between
qq
and
ww
Measurements
550 INDY 144
550 INDY LXT
550 INDY Voyageur
550 INDY ADVENTURE
Yes 0-1/8 in.
(0-3 mm)
550 INDY Voyageur
155
550 INDY ADVENTURE
155
No 1/8-1/4 in.
(3-6 cm)
INDY 121 Yes 0-1/8 in.
(0-3 mm)
INDY EVO
EVO RMK
Yes 5/16-3/8 in.
(8-9.5 mm)
97
MAINTENANCE
Downloaded from ManualsNet.com search engine