Polaris 800 RMK 2011 User Manual

108
TROUBLESHOOTING
Suspension Troubleshooting
Problem Solution
Rear suspension
bottoms too easily
• Refer to the suspension adjustment and set-up information
beginning on page 42.
• Revalve rear track shock (see your dealer).
Rides too stiff in rear • Refer to the suspension adjustment and set-up information
beginning on page 42.
• Check for binding suspension shafts and grease all pivot
points.
Too much weight
transfer when
climbing
• Refer to the suspension adjustment and set-up information
beginning on page 42.
Too little weight
transfer when
climbing
• Refer to the suspension adjustment and set-up information
beginning on page 42.
Machine darts from
side to side
• Check ski alignment (see page 100).
• Make sure spindles and all steering components turn freely.
• Check for excessive play in steering assembly (see your
dealer).
• Ensure skags are straight on skis.
Front end pushes • Check for worn skags.
• Check for binding front suspension shafts and steering
components, grease all pivot points (elevate front of snow-
mobile).
• Increase IFS preload (if equipped) (see page 46).
Steering is heavy • Make sure spindles and all steering components turn freely.
• Check ski alignment (see page 100).
• Check skags and skis for damage.

Polaris 800 RMK 2011 Specifications

General

Engine Type	Liberty
Displacement	795 cc
Track Length	155 in
Track Width	15 in
Track Height	2.4 in
Fuel Capacity	11.5 gal
Bore x Stroke	85 mm x 70 mm
Starter	Electric
Drive Clutch	P-85
Driven Clutch	Team LWT
Height	48 in
Front Travel	9 in
Rear Travel	16 in
Ski Type	Gripper
Carburetion	Mikuni