FILTER SYSTEMS
AIR FILTER
Always change the air filter at the intervals outlined in the Periodic Maintenance
Chart. Service the air filter more frequently if the vehicle is operated in wet
conditions or at high throttle for extended periods.
1. Lift the cargo box to access the air box.
2. Release the air box cover latches and remove the cover.
3. Remove the air filter.
4. Inspect the air box for oil or water deposits. Wipe away any deposits with a
clean cloth.
5. Install a new filter if needed. Do not attempt to clean the air filter.
PVT INTAKE SCREEN
The PVT intake screen is located on the driver’s side of the vehicle.
Inspect the screen before each use of the vehicle. Remove all dirt and debris
from the screen and clean it frequently with warm soapy water.
SPARK ARRESTOR
WARNING
• Never operate the vehicle without the spark arrestor.
• Remove any combustible materials from the area.
Failure to heed the following warnings while servicing the spark arrestor
could result in serious injury or death.
• Never run the engine in an enclosed area. Exhaust contains poisonous
carbon monoxide gas that can cause loss of consciousness or death in a
very short time.
• Do NOT perform service on the spark arrestor while the system is HOT.
Exhaust system temperatures can reach extreme temperatures. Allow
components to cool sufficiently before proceeding.
• Do not stand behind or in front of the vehicle while purging the exhaust
system.
• Never go under the vehicle while it is inclined.
• Wear eye protection and gloves while servicing.
Periodically clean the spark arrestor to remove accumulated carbon.
86
MAINTENANCE
To Next Page
Loading...
Need help?
General
