Polaris Sportsman 400 H.O. User Manual (English)

Questions and Answers:

U
uboyleAug 12, 2025
How to fix irregular running, stalling, or misfiring in my Polaris Offroad Vehicle engine?
- J
  Jennifer FloresAug 12, 2025
  Irregular engine running, stalling, or misfiring in your Polaris Offroad Vehicle can stem from several issues. Begin by inspecting the spark plugs for fouling or defects, and replace them if needed. Check the spark plug gap and heat range, ensuring they meet specifications. Inspect for loose ignition connections and tighten them. Replace the fuel if water is present or if it's incorrect. Inspect and replace a kinked or plugged fuel tank vent line and inspect and clean or replace a clogged air filter. Also, ensure that the battery voltage is not low by recharging it to 12.8 VDC.
W
wgarzaAug 16, 2025
What to do if my Polaris Offroad Vehicle engine turns over but won't start?
- R
  Ryan PettyAug 16, 2025
  If your Polaris Offroad Vehicle engine turns over but fails to start, the following steps may help: * If the vehicle is out of fuel, refuel it, cycle the key to the ON position three times for 5 seconds each, then start. * Inspect and clean or replace a clogged fuel valve or filter. * Drain the fuel system and refuel if water is present in the fuel. * Ensure the fuel valve is turned on. * Replace old or non-recommended fuel with fresh, recommended fuel. * Inspect the spark plugs, and replace them if necessary. * Inspect plugs and verify the stop switch is on if there is no spark to the spark plug. * Inspect, clean and/or replace spark plugs if there is overuse of choke. * Recharge the battery to 12.8 VDC if the battery voltage is low.
C
chavezdanielAug 27, 2025
How do I resolve overheating issues in my Polaris Offroad Vehicle engine?
- J
  Justin ScottAug 27, 2025
  If your Polaris Offroad Vehicle engine is overheating, start by checking the radiator coolant level and add coolant if it's low. Inspect the radiator screen for debris and clean it by pulling on the top portion of the screen, then removing the lower portion. Flush the radiator fins with a garden hose to remove any blockages. Also, make sure the cooling fan isn't obstructed by debris or mud.
L
Lynn SteeleAug 31, 2025
Why won't the engine on my Polaris Offroad Vehicle turn over?
- A
  amanda73Aug 31, 2025
  If your Polaris Offroad Vehicle engine won't turn over, it could be due to a blown fuse, which you should replace. Alternatively, the battery voltage may be low, requiring you to recharge the battery to 12.8 VDC. Also, check for loose battery and solenoid connections, and tighten them if necessary.
D
David ArnoldSep 4, 2025
Why is my Polaris Offroad Vehicle engine pinging or knocking?
- B
  Bryan KelleySep 4, 2025
  If your Polaris Offroad Vehicle engine is pinging or knocking, it could be due to poor quality or low octane fuel; replace it with the recommended fuel. Also, incorrect spark plug gap or heat range can cause this issue; set the gap to specifications or replace the plugs. Adjust the idle speed if it is set too low.
K
Katherine JohnsonSep 8, 2025
What causes a Polaris Offroad Vehicle engine to backfire?
- M
  Mary WilliamsSep 8, 2025
  A Polaris Offroad Vehicle engine can backfire due to a weak spark from the spark plug, which requires you to inspect, clean, and/or replace the spark plug(s). An incorrect spark plug gap or heat range can also cause this; set the gap to specifications or replace the plugs. Replace old or non-recommended fuel with fresh, recommended fuel.