Porter-Cable C2002 - User Manual

Questions and Answers

J
james66Sep 2, 2025
How to troubleshoot a Porter-Cable C2002 Air Compressor when the motor will not run?
- D
  Danielle PenaSep 2, 2025
  If the motor of your Porter-Cable Air Compressor won't run, here are a few things to check: * Blown fuse or tripped circuit breaker: Inspect the fuse box and replace any blown fuses as needed. Reset the circuit breaker. Ensure you're using the correct fuse with the specified rating for your circuit. A time delay fuse is recommended. Also, avoid using a fuse or circuit breaker with a higher rating than specified. * Incorrect extension cord: Verify that the extension cord is the correct length and gauge. * Loose electrical connections: Check the wiring connections inside the terminal box. * Faulty motor: Have the motor checked by a Trained Service Technician.
S
Sandra PowellAug 31, 2025
What to do if there is an air leak from the safety valve on my Porter-Cable Air Compressor?
- I
  ichanAug 31, 2025
  If the safety valve on your Porter-Cable Air Compressor is leaking air, it could be due to a possible defect in the safety valve. Try operating the safety valve manually by pulling on the ring. If the valve continues to leak after that, it should be replaced.
J
John MillerAug 29, 2025
How to fix air leaks between head and valve plate on Porter-Cable C2002?
- A
  Ashley MartinAug 29, 2025
  If there are air leaks between the head and valve plate on your Porter-Cable Air Compressor, this indicates a leaking seal. Contact a Trained Service Technician.
S
stonejessicaAug 27, 2025
What to do if Porter-Cable C2002 has air leak from safety valve?
- W
  williamhernandezAug 27, 2025
  If there is an air leak from the safety valve on your Porter-Cable Air Compressor, it could indicate a defect in the safety valve. Operate the safety valve manually by pulling on the ring. If the valve continues to leak, it should be replaced.
M
Monica HernandezAug 26, 2025
What to do if Porter-Cable C2002 regulator will not shut off air outlet?
- C
  Christina KelleyAug 26, 2025
  If the regulator on your Porter-Cable Air Compressor will not shut off the air outlet, it means that the regulator is damaged and needs to be replaced.
B
Billy AdamsAug 25, 2025
What to do if Porter-Cable C2002 Air Compressor regulator knob has continuous air leak?
- K
  Kathy SmithAug 25, 2025
  If the regulator knob on your Porter-Cable Air Compressor has a continuous air leak, the regulator is likely damaged and needs to be replaced.
J
jenniferortegaAug 22, 2025
How to fix air leaks at fittings on Porter-Cable C2002 Air Compressor?
- G
  Gary WhiteAug 22, 2025
  To fix air leaks at the fittings of your Porter-Cable Air Compressor, tighten the fittings where you hear air escaping. You can also check the fittings with a soapy water solution to identify leaks. Be careful not to overtighten the fittings.

Summary

Safety Guidelines and Definitions

Hazard: Risk of Explosion or Fire

Precautions against fire and explosion hazards.

Hazard: Risk to Breathing (Asphyxiation)

Dangers of inhaling contaminated air from the compressor.

Hazard: Risk of Bursting

Warnings about air tank integrity and potential explosion.

Operational Hazards

Hazard: Risk of Electrical Shock

Safety measures to prevent electric shock.

Hazard: Risk from Flying Objects

Protection against projectiles from the air stream.

Hazard: Risk from Moving Parts

Preventing injury from moving machinery parts.

Usage and Environmental Hazards

Hazard: Risk of Unsafe Operation

Guidelines for safe and responsible compressor usage.

Setup and Installation

Installation Location and Grounding

Proper placement, ventilation, and electrical grounding.

Electrical Requirements

Guidelines for extension cords, voltage, and circuit protection.

Operation Procedures

Know Your Air Compressor

Overview of compressor components and controls.

Description of Operation

Starting and Stopping

Break-in and Pre-Start Checks

Maintenance

Safety Valve and Tank Draining

Troubleshooting

Pressure and Leak Issues

Performance and Regulator Issues

Motor Start-up Problems

Porter-Cable C2002 Specifications

General

Tank Capacity	6 gallons
Max PSI	150 PSI
SCFM @ 90 PSI	2.6 SCFM
Pump Type	Oil-Free
Voltage	120 V
Type	Portable
Power Source	Electric
Amperage	10 Amps
Horsepower	0.8 HP (Peak)