Poulan Pro Deluxe 961120042 User Manual

Loss of power 1. Rear of lawn mower 1. Raise cutting height.
housing or cutting blade
dragging in heavy grass.
2. Cutting too much grass. 2. Raise cutting height.
3. Dirty air fi lter. 3. Clean/replace air fi lter.
4. Buildup of grass, leaves, 4. Clean underside of mower
and trash under mower. housing.
5. Too much oil in engine. 5. Check oil level.
6. Walking speed too fast. 6. Cut at slower walking speed.
Poor cut – 1. Worn, bent or loose blade. 1. Replace blade. Tighten
uneven blade bolt.
2. Wheel heights uneven. 2. Set all wheels at same
height.
3. Buildup of grass, leaves 3. Clean underside of
and trash under mower. mower housing.
Excessive 1. Worn, bent or loose blade. 1. Replace blade. Tighten
vibration blade bolt.
2. Bent engine crankshaft. 2. Contact a qualifi ed service
center.
Starter rope 1. Engine fl ywheel brake is on 1. Depress control bar to
hard to pull when control bar is released. upper handle before
pulling starter rope.
2. Bent engine crankshaft. 2. Contact a qualifi ed service
center.
3. Blade adapter broken. 3. Replace blade adapter.
4. Blade dragging in grass. 4. Move lawn mower to cut
grass or to hard surface.
Grass catcher 1. Cutting height too low. 1. Raise cutting height.
not fi lling 2. Lift on blade worn off. 2. Replace blade.
(If so equipped) 3. Catcher not venting air. 3. Clean grass catcher.
Hard to push 1. Grass is too high or wheel 1. Raise cutting height.
height is too low.
2. Rear of lawn mower 2. Raise rear of lawn mower
housing or cutting blade housing one (1) setting
dragging in grass. higher.
3. Grass catcher too full. 3. Empty grass catcher.
4. Handle height position not 4. Adjust handle height to suit.
right for you.
PROBLEM CAUSE CORRECTION
TROUBLESHOOTING - See appropriate section in manual unless directed
to an authorized Service Center.
193732 Rev. 3 03.26.07 BY Printed in U.S.A.
DELUXE PUSH ROTARY
LAWN MOWER
WARNING: This lawn mower is equipped with an internal com bus tion engine and
should not be used on or near any un im proved forest-covered, brush-covered or
grass-cov ered land unless the engine’s exhaust system is equipped with a spark
arrester meeting applicable local or state laws (if any). If a spark arrester is used, it
should be maintained in effective working order by the operator.
In the state of California the above is required by law (Section 4442 of the California
Public Resources Code). Other states may have similar laws. Federal laws apply
on federal lands. A spark arrester for the muffl er is available through your nearest
authorized service center.

Poulan Pro Deluxe 961120042 Specifications

General

Brand	Poulan Pro
Model	Deluxe 961120042
Category	Lawn Mower
Language	English

Summary

Troubleshooting Lawn Mower Problems

Safety Rules and General Operation

General Operation Safety

Key instructions for safe and responsible operation of the mower.

Slope Operation Safety

Specific safety precautions and procedures for operating the mower on slopes.

Engine Fuel, Oil, and Storage Preparation

Fuel System Storage Precautions

Important precautions for fuel storage and system care.

Engine Oil Maintenance

Instructions for draining and replacing engine oil.

Cylinder Preparation for Storage

Procedure for preparing cylinder for storage.

Battery Handling and Charging

Steps for disconnecting and charging battery.

General Storage Advice

Storage advice for gasoline cans and unit protection.

Lawn Mower Storage Procedures

Prepare Lawn Mower for Storage

Steps for cleaning, lubricating, and checking mower before storage.

Folding Lawn Mower Handle

Instructions for folding the mower handle for storage.

Adjusting Handle Positions for Storage

How to set up adjustable handles from storage position.

Child Safety During Operation

Critical warnings and precautions to ensure child safety during mower operation.

Safe Gasoline Handling

Essential safety guidelines for handling flammable gasoline to prevent accidents.

General Service Safety Checks

General safety advice for servicing and maintenance, including blade safety.

Lawn Mower Assembly and Setup

Remove Mower from Carton

Steps for safely removing the mower from its shipping carton.

Pre-Assembly Knowledge

Information on identifying mower type and engine for operation.

Set Up Mower Handle Height

Instructions for unfolding and adjusting the mower handle height.

Adjust EZ Handle Positions

Guide to setting up the mower's 3-position EZ adjustable handles.

Adjust Quick Handle Positions

Instructions for adjusting the mower's 3-position quick-adjust handles.

Rear Deflector Information

Information on the function and replacement of the rear deflector.

Engine Adjustments

Details on engine carburetor, speed, and throttle control adjustments.

Grass Catcher and Wheel Assembly

Install Rear Wheels

Procedure for installing rear wheels on high wheel mower models.

Assemble Grass Catcher

Steps for assembling and attaching the grass catcher to rear discharge mowers.

Adjusting Cutting Height and Handle

Adjust Cutting Height

Instructions on how to adjust the mower's cutting height.

Adjust Mower Handle

Procedures for adjusting the mower's handle height for comfort.

Remove Mower Blade

Detailed steps for safely removing the mower blade.

Replace Mower Blade

Guide for installing a new or sharpened mower blade.

Regular Maintenance Schedule

Check Fasteners and Tires

Regular checks for loose nuts/bolts and tire condition are crucial for safety.

Clean and Inspect Grass Catcher

Maintaining the grass catcher ensures proper function and safety.

Clean Lawn Mower

Keeping the mower clean enhances performance and longevity.

Engine Oil Level Check

Essential pre-operation check for engine lubrication.

Change Engine Oil

Procedures for changing engine oil as per schedule.

Clean Air Filter

Maintaining the air filter ensures optimal engine performance.

Replace Spark Plug

Replacing the spark plug ensures reliable engine starting.

Fuel System Preparation

Preparing the fuel system for storage or long-term use.

Spark Plug Boot Installation

Instructions for installing the spark plug boot for proper connection.

Battery Preparation

Steps for charging and connecting the battery for electric start models.

Operating the Lawn Mower

Engine Speed Control

How to adjust engine speed using throttle controls or fixed settings.

Fixed Speed Engine Operation

Information for models where engine speed is not adjustable.

Adjust Wheel Height

Instructions for adjusting wheel height on models with bolt-on or quick-adjust wheels.

Mowing Tips

Practical advice for achieving the best results while mowing.

Mulching Mowing Tips

Specific guidance for effective mulching operations.

Before Starting Engine

Essential checks and readings before starting the engine.

Fill Engine Oil

Procedure for filling the engine with the correct type and amount of oil.

Fill Gasoline Tank

Instructions for safely filling the fuel tank with fresh gasoline.

Start Engine

Step-by-step guide to starting the lawn mower engine.

Stop Engine

How to properly stop the lawn mower engine.

Convert Mulching Mowers

Instructions for converting mulching, rear discharge, and side discharge mowers.

Operator Presence Control

Explanation of the operator presence control bar and its safety function.

Empty Grass Catcher

Detailed steps for removing and emptying the grass catcher.