Poulan Pro Deluxe 961420036 User Manual

Loss of power 1. Rear of lawn mower 1. Raise cutting height.
housing or cutting blade
dragging in heavy grass.
2. Cutting too much grass. 2. Raise cutting height.
3. Dirty air fi lter. 3. Clean/replace air fi lter.
4. Buildup of grass, leaves, 4. Clean underside of mower
and trash under mower. housing.
5. Too much oil in engine. 5. Check oil level.
6. Walking speed too fast. 6. Cut at slower walking speed.
Poor cut – 1. Worn, bent or loose blade. 1. Replace blade. Tighten
uneven blade bolt.
2. Wheel heights uneven. 2. Set all wheels at same
height.
3. Buildup of grass, leaves 3. Clean underside of
and trash under mower. mower housing.
Excessive 1. Worn, bent or loose blade. 1. Replace blade. Tighten
vibration blade bolt.
2. Bent engine crankshaft. 2. Contact a qualifi ed service
center.
Starter rope 1. Engine fl ywheel brake is on 1. Depress control bar to
hard to pull when control bar is released. upper handle before
pulling starter rope.
2. Bent engine crankshaft. 2. Contact a qualifi ed service
center.
3. Blade adapter broken. 3. Replace blade adapter.
4. Blade dragging in grass. 4. Move lawn mower to cut
grass or to hard surface.
Grass catcher 1. Cutting height too low. 1. Raise cutting height.
not fi lling 2. Lift on blade worn off. 2. Replace blade.
(If so equipped) 3. Catcher not venting air. 3. Clean grass catcher.
Hard to push 1. Grass is too high or wheel 1. Raise cutting height.
height is too low.
2. Rear of lawn mower 2. Raise rear of lawn mower
housing or cutting blade housing one (1) setting
dragging in grass. higher.
3. Grass catcher too full. 3. Empty grass catcher.
4. Handle height position not 4. Adjust handle height to suit.
right for you.
PROBLEM CAUSE CORRECTION
TROUBLESHOOTING - See appropriate section in manual unless directed
to an authorized Service Center.
193732 Rev. 3 03.26.07 BY Printed in U.S.A.
DELUXE PUSH ROTARY
LAWN MOWER
WARNING: This lawn mower is equipped with an internal com bus tion engine and
should not be used on or near any un im proved forest-covered, brush-covered or
grass-cov ered land unless the engine’s exhaust system is equipped with a spark
arrester meeting applicable local or state laws (if any). If a spark arrester is used, it
should be maintained in effective working order by the operator.
In the state of California the above is required by law (Section 4442 of the California
Public Resources Code). Other states may have similar laws. Federal laws apply
on federal lands. A spark arrester for the muffl er is available through your nearest
authorized service center.

Poulan Pro Deluxe 961420036 Specifications

General

Brand	Poulan Pro
Model	Deluxe 961420036
Category	Lawn Mower
Language	English

Summary

Troubleshooting Lawn Mower Problems

Loss of Power Troubleshooting

Common causes and corrections for reduced engine power in lawn mowers.

Uneven Lawn Cut Issues

Troubleshooting steps for an uneven or poor cut from your lawn mower.

Excessive Vibration Solutions

Identifying and resolving causes of excessive vibration during mower operation.

Starter Rope Difficulty

Causes and corrections for a starter rope that is hard to pull.

Grass Catcher Not Filling

Diagnosing and fixing issues with the grass catcher not collecting clippings.

Hard to Push Lawn Mower

Problems and solutions for a lawn mower that is difficult to push.

Engine Not Starting

Common causes and corrections when the lawn mower engine fails to start.

Lawn Mower Safety Rules

General Lawn Mower Operation Safety

Essential safety guidelines for operating the lawn mower safely.

Safe Operation on Slopes

Precautions and guidelines for safely operating the mower on slopes.

Lawn Mower Storage Procedures

Preparing Mower for Long-Term Storage

Steps to properly prepare and store the lawn mower for off-season.

Folding Handles for Storage

Instructions on how to safely fold the mower handle for storage.

Lawn Mower Assembly and Setup

Unpacking and Initial Mower Setup

Steps for removing the mower from its carton and basic setup.

Understanding Mower Identification

Identifying mower type, discharge, and engine for operation.

Adjusting Mower Handle Height

Setting the handle height for comfortable and safe operation.

Rear Deflector Purpose

Understanding the function of the rear deflector on the mower.

Engine Carburetor and Speed Notes

Information regarding the engine carburetor and speed settings.

Service and Adjustments

Adjusting Lawn Mower Cutting Height

Procedure for setting the desired grass cutting height.

Adjusting Mower Handle Position

How to adjust the handle to different height positions for user comfort.

Installing High Wheel Mower Wheels

Instructions for mounting rear wheels on high-wheel mower models.

Assembling the Grass Catcher

Steps for attaching the grass catcher to rear discharge models.

Lawn Mower Maintenance Schedule

Comprehensive Maintenance Schedule

A detailed schedule for regular lawn mower maintenance tasks.

Spark Plug and Battery Maintenance

Servicing the spark plug and battery for optimal performance.

General Maintenance Recommendations

Important tips and advice for maintaining the lawn mower's condition.

Pre-Operation Checks

Essential checks to perform before starting the mower for each use.

Lubrication Guide and Charts

Guidance on unit lubrication and reference to lubrication charts.

Lawn Mower Operation Guide

Engine Speed Control Adjustment

How to adjust engine speed for different mowing conditions.

Adjusting Cutting Height for Mowing

Setting the cutting height for various lawn conditions.

Effective Mowing Tips

Best practices and advice for efficient and effective lawn mowing.

Mulching Mowing Best Practices

Specific advice for achieving optimal mulching results with your mower.

Before Starting Engine Procedures

Filling Engine Oil

Correct procedure for checking and filling the engine oil.

Filling Gasoline Tank Safely

Instructions for safely filling the fuel tank with gasoline.

Starting the Lawn Mower Engine

Step-by-step guide for safely starting the mower engine.

Stopping the Lawn Mower Engine

The correct procedure for shutting down the mower engine.

Mulching and Discharge Operations

How to switch between mulching, bagging, and discharging modes.