Poulan Pro PR600N22SH User Manual

Loss of power 1. Rear of lawn mower 1. Raise cutting height.
housing or cutting blade
dragging in heavy grass.
2. Cutting too much grass. 2. Raise cutting height.
3. Dirty air fi lter. 3. Clean/replace air fi lter.
4. Buildup of grass, leaves, 4. Clean underside of mower
and trash under mower. housing.
5. Too much oil in engine. 5. Check oil level.
6. Walking speed too fast. 6. Cut at slower walking speed.
Poor cut – 1. Worn, bent or loose blade. 1. Replace blade. Tighten
uneven blade bolt.
2. Wheel heights uneven. 2. Set all wheels at same
height.
3. Buildup of grass, leaves 3. Clean underside of
and trash under mower. mower housing.
Excessive 1. Worn, bent or loose blade. 1. Replace blade. Tighten
vibration blade bolt.
2. Bent engine crankshaft. 2. Contact a qualifi ed service
center.
Starter rope 1. Engine fl ywheel brake is on 1. Depress control bar to
hard to pull when control bar is released. upper handle before
pulling starter rope.
2. Bent engine crankshaft. 2. Contact a qualifi ed service
center.
3. Blade adapter broken. 3. Replace blade adapter.
4. Blade dragging in grass. 4. Move lawn mower to cut
grass or to hard surface.
Grass catcher 1. Cutting height too low. 1. Raise cutting height.
not fi lling 2. Lift on blade worn off. 2. Replace blade.
(If so equipped) 3. Catcher not venting air. 3. Clean grass catcher.
Hard to push 1. Grass is too high or wheel 1. Raise cutting height.
height is too low.
2. Rear of lawn mower 2. Raise rear of lawn mower
housing or cutting blade housing one (1) setting
dragging in grass. higher.
3. Grass catcher too full. 3. Empty grass catcher.
4. Handle height position not 4. Adjust handle height to suit.
right for you.
PROBLEM CAUSE CORRECTION
TROUBLESHOOTING - See appropriate section in manual unless directed
to an authorized Service Center.
193732 Rev. 2 04.19.06 BY Printed in U.S.A.
DELUXE PUSH ROTARY
LAWN MOWER
WARNING: This lawn mower is equipped with an internal com bus tion engine and
should not be used on or near any un im proved forest-covered, brush-covered or
grass-cov ered land unless the engine’s exhaust system is equipped with a spark
arrester meeting applicable local or state laws (if any). If a spark arrester is used, it
should be maintained in effective working order by the operator.
In the state of California the above is required by law (Section 4442 of the California
Public Resources Code). Other states may have similar laws. Federal laws apply
on federal lands. A spark arrester for the muffl er is available through your nearest
authorized service center.

Poulan Pro PR600N22SH Specifications

General

Cutting Width	22 inches
Drive Type	Self-Propelled
Start Type	Recoil
Starter Type	Recoil
Cutting Height Adjustment	6-position
Cutting Height	1.5 - 4 inches
Drive System	Rear-wheel drive

Summary

Troubleshooting Lawn Mower Problems

Loss of Power

Identifies and corrects issues causing a lawn mower to lose power.

Poor Cut - Uneven

Addresses causes for uneven grass cutting and provides solutions.

Excessive Vibration

Details common causes of excessive vibration and their remedies.

Starter Rope Hard to Pull

Explains why the starter rope is difficult to pull and offers corrections.

Grass Catcher Not Filling

Lists reasons why the grass catcher may not be filling and how to fix them.

Hard to Push

Provides solutions for a lawn mower that is difficult to push.

Safety Rules and Precautions

General Operation Safety

Outlines essential safety precautions for operating the lawn mower.

Slope Operation Safety

Details critical safety measures when mowing on slopes.

Child Safety Precautions

Emphasizes safety measures to prevent accidents involving children.

Gasoline Handling Safety

Covers essential safety guidelines for handling gasoline.

General Service Safety

Provides safety instructions for performing maintenance and repairs.

Engine Systems and Maintenance

Fuel System

Information on maintaining the fuel system to prevent gum deposits and ensure proper function.

Engine Oil Management

Guidance on checking and changing the engine oil for optimal performance.

Battery Maintenance

Instructions for maintaining and charging the mower's battery if equipped.

Carburetor Adjustments

Details on the engine's carburetor and its preset adjustments.

Engine Speed Control

Information on managing engine speed settings.

Throttle Control

Instructions related to the throttle control system.

Storage Procedures

Handle Folding for Storage

Instructions on how to fold the mower handle for convenient storage.

Assembly and Setup

Unfolding and Setting Up Handle

Steps for unfolding and adjusting the mower handle to the correct position.

Adjusting Handle Height

Details on how to adjust the handle height for different user preferences.

Installing Rear Wheels

Procedures for installing rear wheels, especially on high-wheel models.

Assembling Grass Catcher

Instructions for attaching the grass catcher to the mower.

Service and Adjustments

Blade Care and Replacement

Guidance on blade maintenance, sharpening, removal, and replacement.

Engine Lubrication and Oil Change

Procedures for lubricating the engine and changing the engine oil.

Spark Plug and Air Filter Service

Maintenance steps for the spark plug and air filter.

Cleaning and General Maintenance

Procedures for cleaning the mower and performing general upkeep.

Maintenance Schedule and Checks

Before Each Use Checks

Essential checks to perform on the lawn mower before starting operation.

Battery Preparation for Storage

Steps for preparing the electric start battery for use and storage.

Operating the Lawn Mower

How to Use Your Lawn Mower

Basic instructions and guidance for using the lawn mower.

Adjusting Cutting Height

Instructions on how to set the cutting height for different grass conditions.

Mowing Tips

Practical advice for efficient and effective lawn mowing techniques.

Mulching Mowing Tips

Specific advice for achieving optimal results when mulching grass.

Starting and Stopping Engine

Before Starting Engine

Pre-operation checks including filling oil and gasoline.

Starting the Engine

Procedures for starting the mower's engine using recoil or electric start.

Stopping the Engine

Correct method for safely shutting down the lawn mower engine.

Mower Conversion Options

Mulcher Plug Type A

Instructions for installing Mulcher Plug Type A for mulching operation.

Combi-Cut Mowers Conversion

Steps to convert Combi-Cut mowers for mulching, bagging, or discharging.

Rear Bagging Setup

Procedure for setting up the mower for rear bagging operation.

Grass Catcher (Rear Bagging)

Instructions for using and emptying the grass catcher.

Side Discharging Setup

Procedure for setting up the mower for side discharging operation.

Operator Presence Control Bar

Function and Safety Importance

Explanation of the operator presence control bar and its safety function.