Pro-Tronik AP680BLC - Error Messages and Troubleshooting; Common Error Message Explanations; Battery Voltage and Connection Errors; System and Short Circuit Errors

Errormessages
BATTERYCHECKHIGH
VOLTAGE

Voltagedetectedoverthe
batteryvoltagesupposedto
bepluggedin
Checkthenumberofcellsandcorrectifnecessary
BATTERYVOLTAGECELL
LOW
Thevoltageofonecellis
toolow
Checkthebatteryandbatterybalance.Ifvoltagetoolowplease
contactthebatterymanufacturertoaskaboutprocesstohandle.
BATTERYVOLTAGECELL
HIGHVOL

Onecellhasatoohigh
voltage
Checkthebatterybalanceandinspectcarefullythebatterytosearch
foranyphysicaldamage.Donotinsistoncharginganddonotlaunch
adischargeprocesswithoutcontactingyourbatterymanufacturer/distributorfirst.
BATTERYVOLERRCELL
CONNECT
Connection/voltageerror Checkallconnectorsandbatteryintegrity
TEMPOVERERR

Temperatureistoohigh Stopanyprocessandwaitforthebatterytocooldownbefore
checkingthebattery.
CONTROLFAILURE

Voltage(input/output/
check)failure
Checkbattery,inputpowersupply/batteryandcontactimediatly
yourdistributorforanyassistance.
REVERSEPOLARITY

Polartyofbattery(output)is
inverted
Checkconnection
CONNECTIONBREAK

Batteryconnectoris
unpluggedor
malfunctionning.
Checkallwiresandconnectors,andbattery.
SHORTERR

ShortCircuitdetected Checkallcables/connectorsandthebalanceconnectorofbattery.
INPUTVOLTERR

Inputpowersupplyvoltage
error
Checkthepowersupply,incaseofuseofabatterycar,itmightbe
dischargedoryoumightneedtosetupalowerinputvoltagelow
limit.Contactyourdistributorforanyadviseorforpowersupply
check.
VOLSELECTERR

Thevoltageyouhavesetup
isnotmatchingthevoltage
detectedbythechargerfor
thebattery.
Checkthebatteryandtheconnections,andspecifycorrectvoltage/numberofcells.ForLithium
Batteries,ifthevoltagecannotbe
detectedcorrectlybythecharger,pleasecontactthebattery
manufacturer/distributor
BREAKDOWN

Hardware/softwareerror Stopanyprocess,disconnectthechargerfrompowersuppllyand
disconnectanybatteryattachedtothecharger.Contactyour
distributortechnicalsupport.