Quincy Compressor QSVI Series - Technical Data Sheet: QSVI 200; General Specifications; Electrical Data

TechnicalData Sheet:QSW 200
General S~ecifications
Drive Motor . . . . . . . . . .. . . . . .. . . . . . . . . . . . . . . . . . .. .. . . . .. . . . .
Drive System
.... . . . . .. . . . . .. . . .. . . . . . .. . . . . . ........ . . . . . .
Inlet Capacity . .. . . . .. . . . . . . . . . . . . . . . . . .... . . . . .. ..... . . .. . .
Maximum Operating Pressure (Continuous) . ...... . . . . . .. . .
Minimum Operating Pressure (Continuous) . . . ..... . . . . . . . ..
Base Pressure . . . . . . . . . . . . . . . . . . ... . . . . .. . . . . . .. . . . . .. . . . . . .
Maximum Ambient Temperature . . . . . . . . . . .. . .. . ..... . . . . . .
Minimum Ambient Temperature.. . . . . . . . .. . . . .. ... . . . . . . . ..
Inlet Connection . . . . . .. . . . . . . . . .. . . . . . . . .. . . . ... .. . . . . . . . . .
Discharge Connection . . . . . . . . . .... . . . . . . .. . . . .. . . . . . . . . . . . .
Rotor Diameter . .. . . . . . . . . . . . . . ... . . . . . . .. . . . .. ...... . . . . . .
Rotor Length . ... . . . . . . . . . . . . . .... . . . . . . . . . . . . .... . . . .. . . . .
Rotor Speed-Male . . . . . . . . . . . . . . .. . . . . . .. . . . . . . ... .. . . .. . .
Rotor Speed-Female . . . . . . . . .. . . . . . .. .. .. . . . ..... . . . . . . . . .
...
Tip Speed . . . . ... . . . . . . . . . . .. . . . . . . .. . .. . . . .. ..... . . . . . . . ..
Maximum Sz@eSpeed .. . . . . . . . . . . . . . . . . . . . . . . . . . .. . .. . . . . . .
Intalce MaJe Bearings . . . . . . .. . . . . . . . . . . . . . .. . ..... . . . . . .. . .
lXschargeMaleBearings . . . . . . . . . . . . . . . . .. . . . ..... . . . . . . . . .
Intake Female Bearings . . . . . . . . . . . . . . . . . .. . .. ..... . . . . . . . . .
Discharge Female Bearings . . . .. . . . . . . . . . . . . . . . .. .. . . . . . . . . .
Disp~acement at Operating Speed . . . . . . . . . . . . ..... . . . . . . . . .
Volumetric Efficiency . . . . .. . . .. . . . . . . . . . . . . . . ..... . . . ... . ..
Electrical Data
Full Load Package BHP(Air-Cooled) . . . . . .. . ..... . . . . . .. ..
Package Electrical Consumption-Air . . . . . . . . . .... . . . . . .. . .
Full Load Package BHP (Water-Cooled) . . . . . ....... . . . . . ..
Package Electrical Consumption - Water . . .. .... .. . . . . . . . . .
Drive Motor Service Factor . . . . ... . . . . . . . . . . . . .. .. .. . . . . . . .
Drive Motor Speed . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .. . . . . . . . .
Fan Motor BHP ... . . . . . . . . . . . . ... . . . . . . . . . . .. . . .. . . .. . . . . .
Specific Power-Air-Cooled ... .. . . . . . . . . . . . . . . ... . . . . . . . . .
Specific Power-Water-Cooled .. . . . . . . . . . . . . . . . . . . . . . .. . . .
Typical Standard Motor Efficiency . . . .. .. . . . . . . ... .. . . . . . . .
Typical High Efficiency Motor
. .. .. . . . . . . . . . . . ... . . . .. . . . . .
...
Typical Premium Efficiency Motor . . . . . . . . .. . . . . . . . . . . .. . . .
Page 14
200 HP
Direct
3,000 ACFM
10”HgV (506 torr)
29.9” HgV (.5 torr)
29.9” HgV (.5 torr)
110 degrees F.
45 degrees F.
8“ NPT
8“ SAE Flange
321 mm
546 mm
3,600 RPM
2,400 RPM
60.5 meters/see.
4,500 RPM
Cylindrical Roller Bearings (x 1)
Tapered Roller Bearings (x 2)
Cylindrical Roller Bearings (x 1)
Tapered Roller Bearings (x 2)
3,377 cm
88.8%
190.7 BHP
152.3 KW
186.2 BHP
149.3 KW
1.15
3,600 KPM
4.5 BHP
6.4 BHW1OO
6.3 BHP/100
93.1’XO
93.6’%0
94.1%
.—-—.
-—_______
—,
..... ——.
-,___
.—.. ——.. .—. ——. —. ——. -——
—----- --. —-_ ~ -——-—.-—. .
.