Rage Comet & Comet ‘R’ Maintenance Guide
Issue 2.0 October 2014
Recommended Maintenance Programme
Check each day of use
• Tyres, for excessive wear or damage
• Tyre Pressures Off Road: Front 5 psi (suggested) *
Rear 10 psi (suggested) *
Tarmac: Front 18 psi (suggested) *
Rear 20 psi (suggested) *
• Foot Brake
• Handbrake
• Steering
• Wheel Nut Torque
• (10mm Stud @ 70Nm / 51 ft lbf)
• (12mm Stud @ 90Nm / 66 ft lbf)
• Ignition Switch
• Fuel Tank for Leaks or Damage
• Engine Oil Level
*Subject to ground conditional
Periodic Checks
Rage recommends operators of their products make a full nut and bolt tightness
check and also give the whole machine a general visual appraisal before each day of
use.
Check every 10 hrs of use or at least six monthly
• Brake Pads
• Drive Shaft Rubber Gaiters
• Clean Air Filter (more often in dusty cond.)
• Seat Fixings
• Brake Lines
• Clutch for slippage
• Wheel Bearings for play
• Gearbox Oil Level (Drain and replace yearly)
• Brake Fluid Level (Drain and replace yearly)
To Next Page