Robalo R160 2019 User Manual

2019ROBALOCENTERCONSOLE
RobaloBoats,LLC.
www.robalo.com  
PreventiveMaintenanceandRepair6
Donotattemptanyrepairsonyourboatunlessqualifiedtodoso.Only
use approved marine replacement parts available from your Robalo
dealer.RobalorecommendshavinganauthorizedRobalodealerdoyour
maintenanceandrepairwork.Yourdealerisqualifiedtomakerepairsor
modificationstoyourboatinsuchamannerastonotcompromise
safety, design integrity, or warranty coverage. This chapter includes
information you can use to do general maintenance and repair. If you
choose to do your boat’s maintenance and repairs, always refer tothe
productmanualsfordetailedinformation.

Engine
Refer to the engine owner’s manual for detailed information about
enginemaintenanceandrepair.Thatmanualhasamaintenanceand
serviceschedulefortheengineonyourboat.

CheckingtheOil(On4‐StrokeModels)

Note:Duringtheengine10‐hourbreak‐inperiod,oras
recommendedbytheenginemanufacturer,Robalorecommends
thatyouchecktheoilleveleverytwohours.

Tochecktheoil:

1. Makesureboatisinthewaterandengineisstopped.
2. Puttheoutboardmotorinanuprightposition(nottilted).
3. Ifengineiswarm,letitcoolfortenminutestoallowoiltodrain
backintotheengineoilpan.Thiswillmakethecheckmore

accurate.
4. Pullengineoildipstickoutofitssleeve,wipeclean,andpush
dipstickbackintothesleeve.Makecertainthedipstickispushed
allthewaybackin.
5. Pull dipstick out again and check oil level on dipstick. The oil
levelmustbebetweentheADDandFULLmarksonthedipstick.
6. IfoillevelisatorbelowtheADDmarkyoumust
addoil.
7. Pushdipstickbackdownintothesleeve.Besureitisalltheway
inandproperlyseated.
Toaddoil:
1. Removeoilfillcapfromvalvecover.
2. Add oil as required toraise the oil level up between the ADD
andFULLmarksonthedipstick.Donotoverfill.Onequart
(0.95liters)ofoilwillberequiredifoillevelwasattheADD
markonthedipstick.AddmoreoilofoillevelwasbelowADD
markondipstick.
3. Checkoillevelafteraddingoil.

Note: Robalo Boats recommends that you use a funnel when you
add oil to prevent spillage and to help keep your engine free of
sur‐facegrimeanddirt.

Important: The Federal Water Pollution Control Act prohibits the
discharge of oil or oily waste into or upon the navigable waters of
the United States or the waters of the contiguous zone if such dis‐
chargecausesafilmorsheenuponoradiscolorationofthesurface
ofthewaterorcausesa sludge oremulsionbeneaththesurfaceof
thewater.Violator
saresubjecttoapenalty.

FuelFilter




WARNING: Gasoline vapor explodes easily.Explosion is likely to cause
fireandmayburnyouanddamageyourboat.AlwaysSTOPengineand
donotsmokeorallowopenflamesinareawhenchangingfilter.

Refer to your engine owner’s manual for detailed information about
checkingandmaintainingthefuelfilter.





71
https://www.boat-manuals.com/

Robalo R160 2019 Specifications

General

Brand	Robalo
Model	R160 2019
Category	Boat
Language	English