t7.
Carburetters: Check the oi I level
in
the
air
valve
dampers; top-up if necessary. Check the
idle
speed and adjust
if
necessary.
8. Control linkages:
Lubricate
the accelerator
linkage and the gear range
selector
controls
(adjacent to the transmission casing)
with
engine
oil.
9.
Electrical
system: Check al I
exterior
lamps,
interior
I amps, warning lamps and devices,
instruments and
air
conditioning controls for
correct operation;
rectify
as necessary.
10.
Handbrake or Parking brake I inkage: Lubricate
the
pivot
pins and pulleys
with
the approved grease.
t 11. lgni
ti
on
system: Check and
if
necessary
adjust the
distributor
dwell angle.
Check the
ignition
timing and adjust
if
necessary.
12.
Propeller shaft (Cars
fitted
with
the four speed
automatic gearbox}: Examine the neoprene seal at
the
front
end
of
the shaft for
serviceability;
rectify
as necessary.
13. Check the
following
levels
and
pressures:
Check the
fluid
level
in
the steering
pump
reservoir
and top-up•if necessary.
Check the level and
specific
gravity
of
the
engine coolant; correct as necessary.
Check the
fluid
level
in
the windscreen
washer reservoir and top-up
if
necessary.
Run
the engine for four minutes then check
'the
fluid
levels
of
the hydraulic systems reservoirs;
top-up
if
necessary with recommended
fluid.
Check and if necessary adjust tyre pressures.
Inspect the tread depth
of
al I
tyres;
al so inspect the
tyres
for damage. Report any defects
to
the Owner.
14
•
Test:
Road
test the
car
for
satisfactory
performance.
Every 20 000 kilometres (12 000 miles)
or
12
months
whichever
is
the earlier
...
t
1.
Air
silencer
and
cleaner: Clean and oi I the
wire
mesh
filter
elements or (dependent upon type
of
filter
fitted),
fit
new paper element(s).
• 2. Battery: Check the
electrolyte
level;
top-up
with
distil
led water
if
necessary.
• 3. Brakes: Inspect footbrake and handbrake
or
parking brake
pad
I inings;
fit
new pads
if
necessary.
VI/hen
renewing footbrake pads examine condition
of
·dust excluders
on
calipers
and renew
if
necessary.
Manually adjust the handbrake or parking
t?rake
caliper
mechanism.
Inspect
all
pipes and connections. Report any
defects to the Owner.
• t4. Carburetters: Check the
air
va Ive damper oi I
levels;
top-up if necessary.
Check and adjust
float
chamber depression.
Check engine
idle
speed and choke
idle
speed;
adjust
if
necessary.
Ensure exhaust emissions comply
with
E.C.E.
Regulation
15,
if
applicable.
• 5. Engine: Change engine oi I and
fit
a new oi I
filter.
• t 6. Engine breather system: Remove and clean the
gauze flame traps
in
the crankcase breather tube.
Clean the adapter
in
the choke
butterfly
housing.
E1
- 2
• 7. Final drive unit: Check the
oil
level; top-up
if
necessary.
•
8.
Front suspension: Inspect the
front
suspension
ball
joint
rubber covers;
if
the covers are damaged,
fit
new
joints
and
covers.
•tg.
Ignition
system:
Fit
new
distributor
contact
breaker points; set dwell angle.
Fit
a new
distributor
cam
lubrication
pad
(if
applicable).
If
a
cam
lubrication pad
is
not
fitted
I
ightly
smear the
cam
with grease. Lubricate the di
stri
but or spindle
(shaft bearings) and automatic advance mechanism
with
clean engine
oil.
Fit
new sparking plugs.
Check
ignition
timing
with
stroboscope and
adjust
if
necessary.
• 10. Steering mechanism:
Lubricate
the steering
mechanism at the
six
grease
points.
Inspect the
rubber covers
on
the
ball
joints;
if
the covers are
damaged the
joints
should
be
dismantled and new
parts
fitted
as necessary.
• 11. Torque converter transmission
(If
fitted):
Change transmission
fluid.
12. Automatic gearbox
(If
fitted):
Drain the
gearbox
and
fluid
coupling;
fi
II with
an
approved
fluid.
13.
Belts
and
belt
tension: Check the condition
and
tension of the belts
driving
the coolant pump,
steering pump, generator
or
the refrigeration
compressor and the alternator
(if
fitted);
adjust
or
replace as necessary.
14. Control I inkages:
Lubricate
the accelerator
linkage
and
the gear range selector
controls
(adjacent to the transmission casing)
with
engine
oil.
15.
Electrical
system:
Ch
eek al I
exterior
lamps,
interior
lamps, warning lamps and
devices,
instruments and
air
conditioning controls for correct
operation;
rectify
as necessary .
16. Handbrake or Parking brake
Ii
nkage:
Lubricate
the
pivot
pins and
pulleys
with approved grease.
17.
Propeller
shaft (Cars
fitted
with
the four speed
automatic gearbox): Examine the neoprene seal at the
front end
of
the shaft for
serviceability;
rectify
as
necessary.
18. Spare wheel carrier:
Lubricate
the spare wheel
carrier lowering
bolt
and mechanism.
19. Check the
following
I eve
Is
and
pressures:
Check the
fluid
level
in
the steering
pump
reservoir;
top·up
if
necessary.
Check the
fluid
level
in
the steering
idler
box
damper; top-up
if necessary.
Check the I evel and
specific
gravity
of
the
engine coolant; correct as necessary.
Check the
fluid
level
in
the windscreen washer
reservoir and top-up
if
necessary.
Run the engine for four minutes then check the
levels
of
the hydraulic systems reservoirs; top-up if
necessary
with
the recommended
fluid.
Check and
if
necessary adjust the tyre pressures.
Inspect the tread depth
of
al I tyres; also
inspect
the
tyres for damage. Report
any defects
to
the Owner.
20.
Test:
Road test the
car
for
satisfactory
performance.
To Next Page
Loading...
