Ryobi RY803325 User Manual

OPERATOR’S MANUAL
MANUEL D’UTILISATION
MANUAL DEL OPERADOR
3300 PSI PRESSURE WASHER
LAVEUSE À PRESSION DE 3300 PSI
LAVADORA A PRESIÓN DE 3300 PSI (22,78 Mpa)
RY803325
NOTICE AVIS AVISO
Do not use E15 or E85 fuel in this
product. It is a violation of federal
law and will damage the unit and
void your warranty. Only use unleaded gasoline containing
up to 10% ethanol.
Ne pas utiliser d’essence E15 ou E85 dans ce produit. Une
telle utilisation représente une violation de la loi fédérale
et endommagera l’appareil et annulera la garantie. Utiliser
seulement de l’essence sans plomb ne contenant pas plus
de 10 % d’éthanol.
No utilice combustibles E15 o E85 con este producto. Esto
constituye una violación a la ley federal, dañará la unidad
y anulará la garantía. Use únicamente gasolina sin plomo
con un contenido de hasta 10 % de etanol.
WARNING: To reduce the
risk of injury, the user must read and
understand the operator’s manual
before using this product.
TABLE OF CONTENTS
 Important Safety Instructions ..............2
 Specific Safety Rules ..........................3
 Symbols .......................................... 4-5
 Features ..............................................6
 Assembly ........................................ 7-8
 Operation ...................................... 9-13
 Maintenance ............................... 14-16
 Troubleshooting ................................17
 Parts Ordering / Service ....... Back Page
AVERTISSEMENT : Pour
réduire les risques de blessures,
l’utilisateur doit lire et veiller à bien
comprendre le manuel d’utilisation
avant d’employer ce produit.
TABLE DES MATIÈRES
 Instructions importantes
concernant la sécurité ........................2
 Règles de sécurité particulières ..........3
 Symboles ........................................ 4-5
 Caractéristiques ..................................6
 Assemblage .................................... 7-8
 Utilisation ...................................... 9-14
 Entretien ...................................... 14-17
 Dépannage ........................................ 18
 Commande de pièces /
réparation .......................... Páge arrière
ADVERTENCIA: Para reducir
el riesgo de lesiones, el usuario debe
leer y comprender el manual del
operador antes de usar este producto.
ÍNDICE DE CONTENIDO
 Instrucciones de seguridad
importantes .........................................2
 Reglas de seguridad específicas ........3
 Símbolos ......................................... 4-5
 Características ....................................6
 Armado ........................................... 7-8
 Funcionamiento ............................ 9-14
 Mantenimiento ............................ 14-17
 Solución de problemas .....................18
 Pedidos de piezas /
servicio ........................... Pág. posterior
SAVE THIS MANUAL FOR
FUTURE REFERENCE
CONSERVER CE MANUEL
POUR FUTURE RÉFÉRENCE
GUARDE ESTE MANUAL
PARA FUTURAS CONSULTAS

Ryobi RY803325 Specifications

General

Brand	Ryobi
Model	RY803325
Category	Pressure Washer
Language	English

Summary

IMPORTANT SAFETY INSTRUCTIONS

SPECIFIC SAFETY RULES

SYMBOLS

FEATURES

KNOW YOUR PRESSURE WASHER

Understand tool, manual, project, and safety rules before use for safe operation.

5-IN-1 CHANGE-OVER NOZZLE

Easily change spray patterns with the 5-in-1 Change-over Nozzle for versatile cleaning.

AUTOMATIC CHOKE SYSTEM

Allows easy starting for cold or hot engines, ready for immediate use.

AUTOMATIC SOAP INJECTION SYSTEM

Apply detergent easily at a 20:1 dilution ratio using the soap tank.

FUEL TANK

Holds a maximum capacity of 0.24 gal. Requires unleaded gasoline only.

HONDA GCV200 ENGINE

Engine enabling 3,300 psi at 2.5 gpm. Refer to the separate engine manual.

HOSE STORAGE

Store rolled high pressure hose on the back of the machine using the stretch strap.

IDLE DOWN

Engine speed reduces when trigger released, saving fuel and reducing noise.

ON/OFF SWITCH

Used with starter to start the engine and to turn the engine off.

STARTER GRIP AND ROPE

Pull the starter grip and rope to start the machine.

THERMAL RELIEF VALVE

Prevents water from reaching harmful levels by releasing small amounts of water.

TRIGGER HANDLE

Provides gripping surface for better control and reduced fatigue during operation.

TRIGGER WITH LOCK OUT

Releases water stream for cleaning; lock out prevents unauthorized use.

ASSEMBLY

RAISING AND LOWERING THE HANDLE

Instructions on how to raise and lower the handle using the release knob.

CONNECTING THE SPRAY WAND TO THE TRIGGER HANDLE

Threaded end of spray wand connects to trigger handle connector. Tighten securely.

CONNECTING THE HIGH PRESSURE HOSE TO THE TRIGGER HANDLE

Screw hose collar clockwise into trigger handle coupler. Tighten securely to prevent leaks.

CONNECTING THE HIGH PRESSURE HOSE TO THE PUMP

Align and screw hose collar clockwise onto pump's threaded outlet. Tighten securely.

CONNECTING THE GARDEN HOSE TO THE PRESSURE WASHER

Connect garden hose to water intake. Observe regulations and ensure minimum 10 ft. clearance.

OPERATION

APPLICATIONS

Use for cleaning various exterior surfaces, objects, and equipment.

ADDING/CHECKING ENGINE LUBRICANT

Instructions for adding and checking engine oil level before starting the unit.

ETHANOL-BLENDED FUELS

Do not use E15 or E85 fuel. Use unleaded gasoline with up to 10% ethanol.

ADDING GASOLINE TO THE FUEL TANK

Safety precautions and detailed steps for adding gasoline to the fuel tank.

STARTING AND STOPPING THE PRESSURE WASHER

Procedures for connecting hoses, checking fluids, starting, and stopping the engine.

USING THE TRIGGER HANDLE

How to hold the trigger handle securely and operate the pressure washer.

INSTALLING/REMOVING NOZZLE

Safety warnings and steps for connecting/disconnecting nozzles to the spray wand.

USING THE 5-IN-1 CHANGE OVER NOZZLE

How to select spray patterns on the 5-in-1 nozzle for different tasks.

NOZZLE SELECTION GUIDE

Chart to select the appropriate nozzle for different cleaning tasks.

USING THE HIGH PRESSURE HOSE

Precautions for handling the high pressure hose to prevent damage and injection injury.

WASHING WITH DETERGENT

Instructions for using detergents and converting for upstream detergents.

USING PUMP PROTECTOR

How to add pump protector to prolong pump life and prevent freeze damage.

MOVING THE PRESSURE WASHER

Instructions on how to safely lift, move, and position the pressure washer.

MAINTENANCE

GENERAL MAINTENANCE

Basic cleaning advice and pre-operation checks for the unit.

NOZZLE MAINTENANCE

How to clean a clogged or dirty nozzle using a paper clip and flushing.

PUMP LUBRICATION

Notes that pump lubrication is not required as it is factory lubricated for life.

PUMP MAINTENANCE

Visual inspection of pump seals for leaks; no user serviceable parts.

STORING THE PRESSURE WASHER

Guidelines for storing the unit, including fuel draining, frost protection, and clearances.

PREPARING FOR USE AFTER STORAGE

Steps to prepare the unit for use after a period of storage.

TROUBLESHOOTING