Service Interval Chart - Page 22
SERVICE INTERVAL CHART
Service Interval Char t
Service Intervals
Please use the following timetables to perform routine
maintenance on your machine. Service procedures
included in this manual but not on this chart are to be
performed on an as needed basis.
IMPORTANT: Avoid machine damage. If you
operate mower in extreme heat, dust or other severe
conditions, service more often than shown below.
Before Each Use
Test safety systems.
Check brakes.
Check tire pressure.
Check/tighten loose hardware.
Check engine oil level.
After First 2 Hours
Adjust blade belt tension.
Change engine oil.
Every 8 Hours
Check brakes.
Check tire pressure.
Check engine oil level.
Every 25 Hours
Sharpen/replace blades.
Lubricatefrontaxle.
Check battery and clean battery terminals.
Check transaxle cooling.
Change engine oil. *
Service air filter pre-cleaner. *
Clean air intake screen. *
Every 50 Hours
Inspect muffler
Every 100 Hours
Check/tighten loose hardware.
Adjust drive belt tension.
Clean engine cooling fins
Replace engine oil filter.*
Replace spark plugs.
Replace air filter paper cartridge. *
Every Season
Adjust blade belt tension.
Service air filter pre-cleaner.
Clean air screen.
Replace spark plugs.
Replace fuel filter.
Before Storage
Check/tighten loose hardware.
Lubricate front axle and mower spindles.
Clean battery terminals.
Change engine oil.
Inspect muffler
To Next Page
Loading...
Need help?
General
