Sea-doo Spark Series User Manual

124
EExxhhaauusstt SSyysstteemm DDrraaiinniinngg
In areas where temperature may
freeze, water trapped in the exhaust
system and intercooler must be
removed.
Using the flushing connector, inject
pressurized air at 379 kPa (55 lbf/in²)
into system until there is no more
water flowing from jet pump.
1. Flushing connector
The following hose can be fabricated
to ease draining procedure.
TTYYPPIICCAALL
1. Flushing connector adapter
2. Hose 12.7 mm (1/2 in)
3. Air hose male adapter
NNOOTTIICCEE
FFaaiilluurree ttoo ddrraaiinn tthhee eexxhhaauusstt ssyyss--
tteemm mmaayy ccaauussee sseevveerree ddaammaaggee ttoo
tthhee eexxhhaauusstt mmaanniiffoolldd..
Remove special tools.
EEnnggiinnee IInntteerrnnaall LLuubbrriiccaattiioonn
1. Remove the seat(s).
2. Remove spark plugs. Refer to
Maintenance Procedures section.
3. By the spark plug holes, lubricate
each cylinder.
SSeerrvviiccee PPrroodduucctt
Lubricant and anti-corrosive or
equivalent
4. Fully depress the throttle lever. De-
pressing the throttle lever will pre-
vent fuel from being injected and
to disable the ignition during en-
gine cranking.
5. Press the START/STOP button to
crank the engine a few turns. This
will distribute the oil on the cylinder
walls.
6. Apply anti-seize lubricant on spark
plug threads, then reinstall them in
the engine. Refer to
Maintenance
Procedures
section.
7. Install the ignition coils. Refer to
Maintenance Procedures section.
EEnnggiinnee CCoooollaanntt TTeesstt
If antifreeze is not replaced, test its
density.
The antifreeze replacement and a
density test should be performed by
an authorized Sea-Doo dealer. Refer
to
Maintenance Schedule .
NNOOTTIICCEE
IImmpprrooppeerr aannttiiffrreeeezzee ddeennssiittyy mmaayy
rreessuulltt iinn ffrreeeezziinngg ooff tthhee lliiqquuiidd iinn
tthhee ccoooolliinngg ssyysstteemm iiff tthhee wwaatteerr--
ccrraafftt iiss ssttoorreedd iinn aann aarreeaa wwhheerree
tthhee ffrreeeezziinngg ppooiinntt iiss aattttaaiinneedd.. TThhiiss
wwoouulldd sseerriioouussllyy ddaammaaggee tthhee
eennggiinnee..
EElleeccttrriiccaall SSyysstteemm
BBaatttteerryy RReemmoovvaall aanndd CChhaarrggiinngg
Contact your authorized Sea-Doo
dealer.
WWAARRNNIINNGG
NNeevveerr cchhaarrggee oorr bboooosstt tthhee bbaatttteerryy
wwhhiillee iinnssttaalllleedd iinn tthhee wwaatteerrccrraafftt..
STORAGE AND PRESEASON PREPARATION

Sea-doo Spark Series Specifications

General

Displacement	899 cc
Hull Material	Polytec
Model	Spark, Spark Trixx
Engine Type	Rotax 900 ACE
Horsepower	60 hp / 90 hp
Fuel Type	Gasoline
Fuel Capacity	7.9 US gal (30 L)
Seating Capacity	2 or 3
Length	120 inches (305 cm)
Width	46 in (117 cm)