Sea Ray Sundancer 240

To Next Page

Owner’s Manual Part Number: MRP 1797143

Sea Ray

Owner’s

Manual

240 Sundancer

Main Page

This Manual5
Your Responsibilities5
Sources of Information5
Dealer Responsibilities6
Warranties6
Hull Identification Number6
Service, Parts and Repair for Your Boat7
About Your Limited Warranty8
Table of Contents9
Safe Boating Means13
Safety13
Safety Labels13
Legally Mandated Minimum Required Equipment14
Fire Extinguishing System14
Carbon Monoxide14
Lifesaving Equipment16
Pfd Classifications16
Additional Recommended Equipment for Safe Operation17
Impaired Operation17
Load Capacity17
Maximum Capacities18
Power Capacity18
Propellers18
Stability19
Maintain Control19
General Considerations19
Weather20
Chart Your Course21
Water Sports21
Swimming21
Skiing21
Diving22
Emergency Situations23
Medical Emergency23
Water Rescue23
Fire23
Flooding, Swamping and Capsizing24
Collisions and Leaking24
Grounding24
Propulsion, Control or Steering Failure24
Safety Hot Lines25
International Requirements25
Environmental Considerations25
Fuel and Oil Spillage25
Waste Disposal26
Excessive Noise26
Wake / Wash26
Nautical Terms27
Key to Symbols on Controls and Prints28
Warning Label Locations30
General Boat Arrangement33
Bow and Stern Cleats33
Supporting the Boat33
Passenger Locations34
Propulsion System36
Basic Boat Dimensions and Clearances37
Specifications37
Deck Layout38
Cabin Layout39
Helm , Gauge & Switch Layout40
Function and Location of Through-Hull Cutouts42
Description of Major Controls43
Gear Shift and Throttle Control43
Trim Tabs44
Power Trim Unit and Gauge45
Trailer Switch46
Engine Alarm System46
Important Gauges46
Smartcraft™ Gauge System46
Tachometer47
Oil Pressure, Water Temperature, Speedometer and Fuel Gauges47
Magnetic Compass47
Navigation and Anchor Lights48
Pre-Launch, Launch and Post-Launch Checklist49
Fueling the Boat50
Gasoline Recommendations50
Boarding51
Personal Flotation Devices (Pfds)51
Passenger Instruction and Location51
Starting the Engine52
Shifting to Drive the Boat53
Stopping the Engine54
Steering System54
Bilge55
Fuel and Oil Spillage55
Drain Plug55
Bilge Pump55
Bilge Blower56
Engine and Stern Drive57
Maintenance and Service57
Vibration and Causes57
Impact to Stern Drive57
Propeller Selection58
Propeller Removal and Installation58
Propeller General Information59
Underwater Gear59
Seacocks & Strainers60
Bilge Layout62
Fuel System63
Electric Fuel Valve63
Diesel Fuel System (Optional)64
Fuel Filter (Diesel)64
Fuel Filter Maintenance (Diesel)64
Fueling Precautions66
Static Electricity and the Fuel System66
General66
Before and During Fueling Checklist66
After Fueling Checklist67
DC System69
Direct Current (DC)69
Recommended Batteries71
Battery Switch71
Ignition Protection71
Fuses71
Main DC Breaker Panel73
Control Station Main73
Cabin Main73
Sump Pump73
Stereo Memory73
Volt Accessory Receptacle74
Lighting74
AC System74
Battery Charger #177
Blank77
To Disconnect Shore Power78
Servicing the Main Distribution Panel79
Battery Charger/Converter80
Ground Fault Interrupter Receptacle (GFI)80
Battery80
Charger #180
Charger #280
Electrolytic Corrosion and Zinc Anodes81
Marine Electronic Cathodic Anti-Corrosion System82
Electrical Schematics82
Layout and Accessory Locations101
Carbon Monoxide Monitor101
Air Conditioning & Heating (Optional)101
T Ostart System102
Water System102
Sanitizing the Water System103
Water Pump and Filter103
Winterizing the Water System104
Shower System104
Fresh Water Washdown105
Dockside Water Inlet105
Gray Water System (Option)106
Head System106
Requirements for Operators106
Portable Head with Pump-Out107
Holding Tank Operation107
Vent Filter108
12 Volt Stereo108
Fire Extinguisher Port109
Manual Fire Extinguishing System Pull Handle110
Safety Pin110
Refrigerator (Optional)110
Canvas110
Installation Tips111
Canvas Care and Maintenance111
Horn112
Spot Light (Optional)112
Summary Guide for Inspection, Service and Maintenance114
Useful Service Information115
Inspection, Service and Maintenance Protocol116
Bilge Area116
Topside and Supplies117
Winterization Checklist for Boats Stored on Land117
Boat Storage117
Engines117
Battery(Ies)117
Head System118
Water System118
Fuel Systems118
Fitting out after Storage119
Fuel System119
Battery(Ies)119
Miscellaneous119
Security Considerations119
Seacock Lubrication120
Quick Reference Checklist121
Boarding the Boat121
Preparing to Depart and after Launching122
Quick Reference Checklist123
While Underway123
Returning to Port123
Securing the Boat124
If the Engine Does Not Start124
After Market Equipment Checklist125
Maintenance Log126
Paint Cleaning Agents and Other Substances127
Fiberglass and Gelcoat127
Keep Bilge Area Dry127
Stains and Scratches128
Permanently Moored or Docked Boats128
Care for Bottom Paint128
Topside Areas128
Stainless Steel and Alloy Fittings128
Salt Crystals128
Gauge and Switch Panels129
Acrylic Plastic Sheeting (Plastic Glass)129
Canvas and Clear Vinyl129
Exterior Upholstery Fabric130
Interior Upholstery Fabric130

Brand	Sea Ray
Model	Sundancer 240
Category	Boat
Language	English

Sea Ray Sundancer 240 - User Manual

Table of Contents

Sea Ray Sundancer 240 Specifications

Related product manuals