Skyjack 4632 - Page 184

SECTION 6, Page 103
SJIII Series - The Conventionals 129919
Figure 6.6-1. Electrical Panel Assembly - ANSI/SIA and CSA
Index
No.
Skyjack
Part No.
DescriptionQty.
1 117325 2 CIRCUIT BREAKER, 15 Amp
2 132661 1 WELDMENT, Electrical panel
112495 1 • BOLT
, Hex Head 1/4”-20 x 3/8” Gr. 5
3 125893 1 BUMPER, Female
4 103336 1 HOURMETER
5 103101 1 CONT
ACTOR
103962 2 • SCREW, Machine #10-32 x 1/2" lg.
104003 2
• NUT, Hex #10-32
6 103057 1 BEEPER, 24 V
olt
7 (Ref.) - FLASHING LIGHT OPTION, Flasher
(For components, refer to Figure 6.2-6)
132793 1 • CLAMP
, Plastic (1 1/4”)
8 132794
1 CLAMP, Cable Bundle (1 3/8”)
9 108589 3 RELAY, 24 Volt
10 116711 1 SPACER, Relay Mounting Stand
104546
1 • SCREW, Round hd #10-32 x 2”
104003 2 •
NUT, Hex #10-32
104694 2 • WASHER, Flat #10
11 129182 1 RESISTOR. Proportional Speed 30 Ohm
12 103011 1 STRIP
, Terminal block 11P
103011 1 STRIP, Terminal block 12P
103956 5
• SCREW, Round Hd #6-32 x 1”
103985 5 • NUT, Hex #6-32
13 132657 1 HARNESS, “O2” Wire
14 129171 1 HARNES
S, Holding Valve - One Lift Cylinder (Model 3220/4620)
129170 1 HARNESS, Holding Valves - Two Lift Cylinders (Model 4626/4632)
15 117902
1 HARNESS ASSEMBL
Y, Main Manifold
16 119641 1 CABLE ASSEMBL
Y, Electrical Panel control (No Option)
102888 67" • CABLE, Control 16/10
102518 1 • CONNECTOR, 10 Pole
119456 1 • COVER, Connector
119457
2 • DOWEL, Plastic
17 132869 1 HARNESS, Charger Cut-out
105269
156” • CABTIRE, 14/3
116992 1 • HOUSING, 2-Pole Plug Male
116990
2 • PIN, Female Wire
18 119730 1 CABLE AS
SEMBLY, Electrical Panel Control (All Option)
107821 1 •
CONNECTOR, Female
102887 73” • CABLE, Control 16/15
119727 2
• PIN, Code
19 (Ref.) - SWITCH ASSEMBLY, High Speed & Pothole Override Limit
- (For components, refer to Figure 6.2-7)
2
0 (Ref.) 1 SWITCH ASSEMBLY
, Tilt
- (For components, refer to Figure 6.3-12)
21
(Ref.) - HARNESS, Base Control Box and Tilt Switch
(For components, refer to Figure 6.3-11)
22 132205 1 HARNES
S ASSEMBLY
, Rear manifold
119133 1
• KIT, 8 Pole plug connector
23 (Ref.) - LIMIT SWITCH ASSEMBLY, Pothole protection
- (For components, refer to Figure 6.3-2)
24 110699 1 CAPACITOR, (0.47UF 50V)
L (Ref.) AR LABELS
-
(Refer to Figure 6.8-3)
AH