Snorkel TB80 User Manual

Table of Contents
TB80/TB85J – 0112622EE
Chapter 7 – Prestart Inspection
Operator’s Manual .................................................... 27
Engine ..................................................................... 27
Oil Level ................................................................ 27
Coolant ................................................................. 27
Radiator ................................................................ 27
Fuel Tank .............................................................. 28
Fuel Line............................................................... 28
Air Filter ................................................................ 28
Charging System .................................................. 28
Cold Weather Start Kit—Block Heater .................. 28
Electrical System ..................................................... 28
Emergency Power Battery .................................... 28
Battery Fluid Level ................................................ 29
Battery Terminals .................................................. 29
Cables and Wiring Harness ...................................... 29
Hydraulic System ..................................................... 29
Fluid Level ............................................................ 29
Fluid Filter ............................................................ 29
Hoses, Tubes, and Fittings ................................... 30
Tires and Wheels ..................................................... 30
Axle/Boom Interlock ................................................. 30
Lower Control Station ............................................... 31
Operating Controls ................................................ 31
Emergency Stop ................................................... 31
Emergency Power ................................................ 31
Emergency Lowering ................................................ 31
Level Sensor ............................................................ 32
Flashing Light .......................................................... 32
Sandblast Protection Kit .......................................... 32
Structures ................................................................ 32
Weldments ........................................................... 32
Slide Pads ............................................................ 32
Wire Ropes ........................................................... 33
Fasteners ............................................................. 33
Upper Control Station ............................................... 34
Guardrail System .................................................. 34
Lanyard Anchors .................................................. 34
Operating Controls ................................................ 34
Emergency Stop ................................................... 35
Emergency Power ................................................ 35
Horn ..................................................................... 35
Electrical Power Outlet ......................................... 35
Drive Motion Alarm................................................ 35
Driving and Work Lights ........................................ 35
Platform Control Cover .......................................... 35
Tow Kit ..................................................................... 35
Placards and Decals ................................................ 35
Prestart Inspection Checklist ................................... 40
Chapter 8 – Operation
Cold Weather Start-Up ............................................. 41
Engine Cold Weather Start Kit ................................. 41
Cummins — Block Heater .................................... 41
Cummins — Ether Injection .................................. 41
Deutz — Manifold Preheater ................................. 42
Hydraulic System Cold Weather Warm-Up............... 42
Hydraulic System Warm-Up Switch ...................... 42
Manually Warming The Hydraulic System ............ 42
Preparing for Operation............................................. 42
Lower Controls ......................................................... 42
Axle Controls ........................................................... 43
Extending The Rear Axles .................................... 43
Retracting The Rear Axles .................................... 44
Upper Controls ......................................................... 44
Boom Operation.................................................... 44
Platform Overload Sensing System ....................... 45
Driving and Steering .............................................. 45
Drive Speeds ........................................................ 46
Motion Warning Alarm .......................................... 46
Four Wheel Drive ...................................................... 46
High Range Speed Selector .................................. 46
AC Generator ........................................................... 47
Air Line .................................................................... 47
Driving Lights............................................................ 47
Platform Work Lights ............................................... 47
Chapter 9 – Stowing and Transporting
Stowing .................................................................... 49
Tucked Stow – TB85J ........................................... 49
Transporting ............................................................. 49
Driving ................................................................... 50
Winching .............................................................. 50
Hoisting ................................................................ 51
Securing for Transport ........................................... 52
Chapter 10 – Emergency Operation
Emergency Power System ....................................... 53
Lower Controls ...................................................... 53
Upper Controls ...................................................... 53
Emergency Lowering ................................................ 54
Towing ...................................................................... 54
Chapter 11 – Troubleshooting
Troubleshooting Chart .............................................. 57
Appendix A – Glossary
Limited Warranty

Snorkel TB80 Specifications

General

Brand	Snorkel
Model	TB80
Category	Lifting Systems
Language	English