Sony HCD-SC5 User Manual

HCD-SC5/SC6/SC8
AEP Model
UK Model
E Model
HCD-SC5/SC6/SC8
Australian Model
HCD-SC6/SC8
SERVICE MANUAL
SACD/DVD RECEIVER
Sony Corporation
Home Audio Company
Published by Sony Engineering Corporation
9-961-137-01
2003I1678-1
© 2003.09
HCD-SC5/SC6/SC8 are the amplifier, DVD/
SACD and tuner section in DAV-SC5/SC6/SC8.
Ver 1.0 2003. 09
SPECIFICATIONS
Model Name Using Similar Mechanism NEW
Mechanism Type CDM80-DVBU24
Optical Pick-up Name TDP022W
OUT):
Voltage: 1 V
Impedance: 1 kilohm
Phones Accepts low-and high-
impedance headphones.
Super Audio CD/DVD system
Laser Semiconductor laser
(Super Audio CD/DVD: λ
= 650 nm)
(CD: λ = 780 nm)
Emission duration:
continuous
Signal format system NTSC or NTSC/PAL
Frequency response (at 2 CH STEREO mode)
DVD (PCM): 2 Hz to 22
kHz (±1.0 dB)
CD: 2 Hz to 20 kHz (±1.
0
dB)
Harmonic distortion Less than 0.03 %
Outputs VIDEO 1 (AUDIO
VIDEO 1:
Sensitivity: 150 mV
Impedance: 50 kilohms
VIDEO 2:
Sensitivity: 300 mV
Impedance: 50 kilohms
(Other models)
Tuner section
System PLL quartz-locked digital
synthesizer system
FM tuner section
Tuning range 87.5 – 108.0 MHz (50 kHz
step)
Aerial FM wire aerial
Aerial terminals 75 ohms, unbalanced
Intermediate frequency 10.7 MHz
AM tuner section
Aerial AM loop aerial
Intermediate frequency 450 kHz
Vi
(AEP, UK and Russian models)
deo section (VIDEO 1, 2, EURO AV)
Inputs Video: 1 Vp-p 75 ohms
Outputs Video: 1 Vp-p 75 ohms
Amplifier section
Stereo mode 90 W + 90 W (4 ohms at
1 kHz, THD 10 %)
Surround mode Front: 90 W + 90 W
100 W + 100 W (4 ohms
at 1 kHz, THD 10 %)
(HCD-SC6/SC8)
100 W + 100 W (4 ohms
at 1 kHz, THD 10 %)
(HCD-SC6/SC8)
(HCD-SC5)
(HCD-SC5)
(HCD-SC5)
(HCD-SC5)
100 W + 100 W
(HCD-SC6/SC8)
Centre*:
90 W
(HCD-SC6/SC8)
(HCD-SC5/SC6)
100 W
Surround*: 90 W + 90W
(4 ohms at 1 kHz, THD
10 %)
*Depending on the sound field settings and the source,
there may be no sound output.
Inputs VIDEO 1/VIDEO 2/TV:
Sensitivity: 150 mV
Impedance: 50 kilohms
(AEP, UK and Russian
models)
Subwoofer*: 100 W
(4 ohms at 100 Hz, THD
10 %)
Tuning range
AEP, UK, Russian, Australian, Singapore and
Middle Easten models: 531 – 1,602 kHz (with the
interval set at 9 kHz)
Video section (Other models)
Inputs Video: 1 Vp-p 75 ohms
Outputs Video: 1 Vp-p 75 ohms
S video:
Y: 1 Vp-p 75 ohms
C: 0.286 Vp-p 75 ohms
COMPONENT:
Y: 1 Vp-p 75 ohms
P
B/CB, PR/CR: 0.7 Vp-p
75 ohms
General
Power requirements
European models: 230 V AC, 50/60 Hz
Australian and Asian models:
220 – 240 V AC, 50/60 Hz
Taiwan models: 120 V AC, 50/60 Hz
Other models: 110 – 120 V AC, 50/60 Hz
Dimensions (approx.) 380 × 60 × 337 mm (w/h/d)
incl. projecting parts
Mass (approx.) 4.2 kg
Operating temperature 5°C to 35°C (41°F to 95°F)
Operating humidity 5 % to 90 %
Other models: 531 – 1,602 kHz (with the
interval set at 9 kHz)
530 – 1,710 kHz (with the
interval set at 10 kHz)
Design and specification are subject to change without
notice.
PHOTO: HCD-SC5

Sony HCD-SC5 Specifications

General

Brand	Sony
Model	HCD-SC5
Category	Receiver
Language	English

Summary

Servicing Notes and Model Identification

Handling Optical Pick-up and Laser Diode

Notes on handling optical pick-up, laser diode emission check, and model identification.

Model Identification and Part Numbers

Back panel model identification and associated part numbers for different regions.

General Overview of Controls and Connections

Front Panel Controls Overview

Description and page references for front panel buttons, display, and sensors.

Rear Panel Connections (HCD-SC5/SC6)

Details rear panel input/output jacks for HCD-SC5/SC6 models across regions.

Rear Panel Connections (HCD-SC8)

Details rear panel input/output jacks for HCD-SC8 models across regions.

Remote Control Functions

List of remote control buttons and their corresponding functions and page numbers.

Disassembly Procedures

Front Panel and Side Panel Disassembly

Procedure for removing the front panel and side panels (L/R).

DDCON, FL, and Power Board Removal

Steps for disassembling DDCON, FL, and Power boards.

I/O, SCART, DVD, and AMP Board Disassembly

Instructions for removing I/O, SCART, DVD, and AMP boards.

Mechanism Deck and Chassis Disassembly

Procedures for disassembling the CD mechanism deck and chassis top.

Lever, Gear, and Base Unit Disassembly

Details on removing various levers, gears, and base unit components.

RF, Driver, and Optical Pick-up Disassembly

Steps for removing RF board, driver board, and optical pick-up.

Test Mode Procedures

Version, Key, and Display Test Modes

Procedures for entering and using version, key, and display test modes.

OSD, Disc Slot Lock, and CDM Ship Modes

Instructions for OSD, disc slot lock, repeat limit release, and CDM ship modes.

Test Mode Sub-functions and Disc List

Details on Syscon Diagnosis, Drive Adjustments, and required test discs.

Electrical Adjustment Procedures

Test Disc List for Adjustments

List of specific test discs required for electrical adjustments.

Auto Servo Adjustment Procedure

Steps for re-adjusting the servo circuit after parts replacement.

Circuit Diagrams and Waveforms

Circuit Boards Location Overview

Diagrams showing the physical location of all circuit boards in the unit.

Block Diagrams - RF, Servo, Audio, Video Sections

High-level block diagrams illustrating signal paths for key sections.

Printed Wiring Boards - RF, Driver, and DVD Sections

Layouts for RF, Driver, and DVD section printed wiring boards.

Schematic Diagrams - RF, Driver, and DVD Sections

Detailed circuit schematics for RF, Driver, and DVD sections.

Printed Wiring Boards - AMP, I/O, and Front Panel Sections

Layouts for AMP, I/O, and Front Panel section printed wiring boards.

Schematic Diagrams - AMP, I/O, and Front Panel Sections

Detailed circuit schematics for AMP, I/O, and Front Panel sections.

Printed Wiring Boards - Power Section

Layouts for Power section printed wiring boards.

Schematic Diagrams - Power Section

Detailed circuit schematics for the Power section.

Waveforms - RF and DVD Boards

Oscilloscope waveforms for RF and DVD board signals.

IC Block Diagrams

Block diagrams illustrating the internal functions of key ICs.

Exploded Views of Assemblies

Case and Front Panel Exploded Views

Exploded views of external case and front panel components.

Chassis and Mechanism Deck Exploded Views

Exploded views of chassis sections and mechanism deck assemblies.

Base Unit Exploded View

Exploded view of the base unit and its associated components.

Electrical Parts List

Amplifier Section Parts List

List of electronic components for the amplifier section with part numbers.