Stanley j5c09 User Manual


overheat. In such event, compressor may automatically shut down. Turn off the Compressor Power Switch immediately and restart

SPECIFIC SAFETY INSTRUCTIONS FOR JUMP STARTERS
WARNING: BURST HAZARD
Do not use the unit for charging dry-cell batteries that are commonly used with home appliances. These batteries may burst and

supply power to a low-voltage electrical system other than in a starter-motor application.

electrical shock and injury to persons.
WARNING: RISK OF EXPLOSIVE GASES

For this reason, it is of the utmost importance that each time before using the jump-starter you read this manual and follow


manufacturer of any equipment you intend to use in the vicinity of the battery. Review cautionary markings on these products
and on the engine.
CAUTION: TO REDUCE THE RISK OF INJURY OR PROPERTY DAMAGE:
•NEVERATTEMPTTOJUMP-STARTORCHARGEAFROZENBATTERY.




aware of first aid procedures in case of accidental contact with battery acid.



battery can produce a short circuit current high enough to weld a ring, or similar metal object, to skin, causing a severe burn.

electrical sparks.




clamps, cords, clothing and body parts away from moving vehicle parts.



(BLACK) clamp to the vehicle chassis or engine block away from the battery. Do not connect the clamp to the carburetor, fuel
lines or sheet-metal body parts. Connect to a heavy gauge metal part of the frame or engine block.


fuel lines or sheet-metal body parts. Connect to a heavy gauge metal part of the frame or engine block.

and the unit will sound a beep. Disconnect clamps and reconnect to battery with correct polarity.

grounded systems.

heavy-duty electrical tape to prevent shorting (shorting can result in injury or fire).




system.

have a battery installed.

attempts, discontinue jump-start procedures and look for other problems that may need to be corrected.
• Stayalert. Watch what you are doing. Use common sense. Do not operate appliance when you are tired.
• Checkfordamagedparts. Any part that is damaged should be replaced by the manufacturer before further use.
• Donotoperatethisappliancenearflammableliquidsoringaseousorexplosiveatmospheres.Motors in these
tools normally spark, and the sparks might ignite fumes.
• Neversubmergethisunitinwater;
• Toreduceriskofelectricshock, disconnect the unit from any power source before attempting maintenance or cleaning.
Turning off controls without disconnecting will not reduce this risk.
• Thisequipmentemploysparts(switches,relays,etc.)thatproducearcsorsparks.Therefore, if used in a garage or
enclosed area, the unit MUST be placed not less than 18 inches above the floor.
• Donotusethisunittooperateappliancesthatneedmorethan5ampstooperatefromthe12voltDCaccessory
outlet.
• DonotinsertforeignobjectsintoeithertheUSBoutletorthe12voltDCaccessoryoutlet.
SPECIFIC SAFETY INSTRUCTIONS FOR CHARGING THIS UNIT
• IMPORTANT:
for a full 24 hours before using for the first time. You cannot overcharge the unit using the AC charging method.
• 
position before connection to a power source or load.
WARNING: SHOCK HAZARD
•Outdooruseextensioncords.
•Extensioncords.
enough to carry the current your product will draw. An undersized cord will cause a drop in line voltage resulting in loss of power
and overheating. The following table shows the correct size to use depending on cord length and nameplate ampere rating. If in

MINIMUM GAGE FOR CORD SETS
Volts Total Length of Cord in Feet
    
(0-7.6m) (7.6-15.2m) (15.2-30.4m) (30.4-45.7m)
    
(0-15.2m) (15.2-30.4m) (30.4-60.9m) (60.9-91.4m)
AmpereRating ExtensionCordLength
More Not more
0’-25’ 26’-50’ 51’-100’ 101’-150’
Than Than AmericanWireGage(AWG)
0 - 6 18 16 16 14
6 - 10 18 16 14 12
10 - 12 16 16 14 12
12 - 16 14 12 Not Recommended
•Whenanextensioncordisused, make sure that:


c) the wire size is large enough for the AC rating of the charger.
CAUTION: TO REDUCE THE RISK OF INJURY OR PROPERTY DAMAGE: Pull cord by plug rather than cord when disconnecting

CAUTION:TOREDUCETHERISKOFPROPERTYDAMAGEWHENCHARGINGUSINGTHE12VOLTDCMETHOD:


SPECIFIC SAFETY INSTRUCTIONS FOR COMPRESSORS
CAUTION: TO REDUCE THE RISK OF INJURY OR PROPERTY DAMAGE: Never leave the compressor unattended while in use.
WARNING: BURST HAZARD:



CAUTION: TO REDUCE THE RISK OF PROPERTY DAMAGE:
J5C09_ManualENSP_031113.indd 4-5 3/11/2013 11:27:13 AM

Stanley j5c09 Specifications

Power

boost ampere	12Vdc, 500A instantaneous, 5 seconds 300A
battery type	Maintenance-free, sealed lead acid, 12 volt DC, 19aH
usb port	5Vdc, 500mA

Operating Environment

compressor maximum pressure	120 PSI
dc accessory outlet	12Vdc, 5A
area light	1 long-life white LED