Tatuus T318 - Annexes; Tightening Torque

To Next Page

To Previous Page

Release 3.00 (22/06/2020)

Page 189

16 ELECTRONIC & SOFTWARE

16.1 ELECTRONIC

Refer to engine builder docs.

Main Page

Table of Contents2
General Information8
Releases8
Release List8
Technical Contacts9
Chassis9
Engine9
Gearbox10
Electronic10
Tires10
Brakes11
Dampers11
Seat Belts - Fire Extinguisher11
General Agreement and Warranty12
Overview13
General Information14
Mileage Chart16
Safety19
Survival Cell19
Extractable Seat20
Driver Padding21
Seat Belts21
Front Impact Structure22
Retention System Adjustment22
Front Nose Repair Specification and Procedure23
Applicable Requirements23
Replacement Procedure23
Rear Impact Structure25
Side Impact Structure25
Halo26
Installation Procedure26
Disassembly Procedure35
Steering Column38
Wheel Tethers38
Rear Crashbox Tethers38
Fire Extinguisher39
Fuel Cell41
Rain Light41
Rain Light Modes41
Clutch Disengagement42
FIA Throttle Fail Safe42
Chassis43
Workshop Tools43
Front Jacking43
Rear Jacking44
Setup Tools45
Front References45
Rear References46
Wheel Hub47
Standard Set-Up48
Road Course Set-Up48
Weight and Ballast49
Controls and Display53
Cockpit Controls53
Steering Wheel Controls54
Steering Wheel Display55
Page #1: Driver Page56
Page #2: Setting Page57
Page #3: Logger Page59
Page #4: Electric Power Distribution60
Page #5: Engine Warmup61
Page #6: Gearbox Page62
Driver Installation63
Steering Wheel Position63
Pedals64
Brake Pedal65
Throttle Pedal66
Clutch Pedal67
Heel Rest68
Brake Bias69
Aerodynamic70
General Notes70
Front Wing Setting71
Rear Wing Setting72
Aerodynamic Reference Setup73
Ride Height Sensitivity74
Wing Sensitivity77
Wing Sensitivity, both the Front Flaps On, Without Gurney Flap Installed78
Wing Sensitivity, both the Front Flaps On, with Gurney Flap (190Mmx15Mm) Installed80
Wing Sensitivity, Only Lower Front Flaps On, Without Gurney Flap Installed82
Wing Sensitivity, Only Lower Front Flaps On, with Gurney Flap (250Mmx15Mm) Installed84
Diffuser86
Suspensions87
Measurement Standard87
Geometry Adjustments88
Ride Height Adjustment88
Camber Adjustment89
Toe Adjustment89
Caster Adjustment90
UMP Adjustment91
Vertical Stiffness92
Front Vertical Stiffness92
Rear Vertical Stiffness92
Dampers93
Rolling Stiffness95
Front Roll Stiffness95
Rear Roll Stiffness95
Suspension Geometry96
Front Suspension Geometry96
Rear Suspension Geometry97
Anti-Effects99
Front99
Rear100
Suspension Maintenance101
Upright Maintenance101
Upright Disassembly102
Upright Assembly106
Steering108
Steering Geometry108
Standard Ratio: 8 Teeth Pinion108
Option Ratio: 7 Teeth Pinion108
Steering Maintenance109
Wheels and Tires110
Wheels110
Tires111
Giti Tires111
Pirelli112
Static Measurements112
Dynamic Measurements113
Operating Instructions113
Technical Limitations - F3 Regional114
Static Measurements114
Dynamic Measurements 230/570-13X10.0J SLICK @ 1.4Bar (20.5Psi), CA 0.0115
Static Radial Deflection 230/570-13X10.0J @ CA 0.0° SLICK116
Static Radial Deflection 230/570-13X10.0J @ CA 3.0° SLICK118
Dynamic Measurements 300/590-13X12.0J SLICK @ 1.4Bar (20.5Psi), CA 0.0120
Static Radial Deflection 300/590-13X12.0J @ CA 0.0° SLICK121
Static Radial Deflection 300/590-13X12.0J @ CA 3.0° SLICK123
Hankook125
Tyre Characteristics (Static Measurement)127
Dimension127
Static Radial Deflection (Kv)128
Tyre Characteristics (Dynamic Measurement)132
Dynamic Measurements 230/560R13 F200(10J) Slick @ 1.5Bar, CA 0.0132
Dynamic Measurements 280/580R13 F200(12J) Slick @ 1.5Bar, CA 0.0133
Dynamic Measurements 230/560R13 Z217(10J) Rain @ 1.5Bar, CA 0.0134
Dynamic Measurements 230/560R13 Z217(10J) Rain @ 1.5Bar, CA 0.0135
Dynamic Measurements 280/580R13 Z217(12J) Rain @ 1.5Bar, CA 0.0136
Operating Temperature137
Tyre Care Information (Technical Limitations)138
Brake System141
Technical Notes141
Balance Bar141
Brake System Setup141
Brake System Bedding-In142
Cooling System143
Fuel System143
Fuel Tank143
Fuel Drain Procedure143
Fuel Coupling143
Fuel Machine Options144
Oil System145
Alfa Romeo Oil Tank145
Renault Oil Tank146
Toyota Oil Tank147
Electric System148
Overview148
Main Switch149
Battery and Alternator150
Battery Installation150
Jump Battery150
Powerbox151
Alfa Romeo Configuration151
Renault Configuration152
Toyota Configuration152
Wiring Loom153
Radio Plug153
Sensors154
Vref List155
Alfa Romeo Configuration V REF List155
Renault Configuration155
REF List155
Engine156
Transmission157
Ratio Chart157
Gear Option 01158
Gear Option159
Differential160
Lubrication161
Particular Precautions161
Storage and Use161
Washing under Pressure161
Glue Components162
Special Tools162
Gear Maintenance163
Removal163
Refitting165
Selector Fork Adjustment166
Differential168
Removal168
Dismantling the Differential Elements168
Refitting the Differential Elements168
Crown-Wheel Replacement169
Secondary Shaft169
Crown175
Exploded Views179
Layshaft179
Mainshaft180
Barrel and Forks181
Differential182
Main Case183
Selection and Reverse184
Oil Pump185
Rebuilding of the Gearbox186
Sadev Workshop Rebuilding186
Private Revision186
Shift System187
System Overview187
Gearshift Control187
ESA Resting Position188
ESA Maintenance189
Electronic & Software190
Electronic190
Annexes191
Tightening Torque191

Tatuus T318 - Annexes; Tightening Torque

Table of Contents