TCM FB20-7 - Page 93

rPrHOCVPrENALIVINAL „гт „гоз
To
ensure
the
safety
in
operation
and
performance
of
the
lift
truck,
be
sure
to
check
the
following
daily
before
starting
the
operation.
A CAUTION
e If any abnormality is found in preoperational checks,
hang a sign of DO NOT OPERATE on the control area,
remove the start key, and report the condition to the
supervisor. The operation should be halted until the
truck is completely repaired.
e Check for oil leaks as it may cause a fire.
e Waste fluid due to lubricant changes should not be
thrown away (into sewage, earth, or incinerater, etc.).
It will cause water, soil, and air pollution and the
responsible personnel will be punished by law.
CAUTION IN CHECKING
Use TCM's genuine parts only.
Use TCM's genuine or recommended lubricants only.
Clean the oil fillers and grease fittings using a brush or cloth
before supplying oil or greasing.
Oil level checks and supply should be performed with the truck
parked on the level surface.
Preventive maintenance services should be done in an orderly
manner with utmost care to prevent personal injury.
Make sure to remove the battery receptacle before checking
electrical equipment.
|f an inspection should be carried out under the raised forks, fix
them by placing stable supports between the fork mast inner
frame and the ground to prevent the forks from falling down.
Any time the truck or controls are found to malfunction, stop the
operation of the truck immediately and report the condition to
the supervisor. Never operate a faulty truck.